2b Estee TS78MOOLA Series (ip) RoHS 3-Terminal 500mA Positive Voltage Regulator Nu COMPLIANCE TO-220 TO-252 Pin Definition: . (DPAK) 1. Input a? 2. Ground (tab) Ms 7 3. Output TTI 123 123 General Description The TS78MOOLA Series positive voltage regulators are identical to the popular TS7800A Series devices, except that they are specified for only half the output current. Like the TS7800A devices, the TS78MOOLA Series 3-Terminal regulators are intended for local, on-card voltage regulation. Internal current limiting, thermal shutdown circuitry and safe-area compensation for the internal pass transistor combine to make these devices remarkably rugged under most operating conditions. Maximum output current with adequate heatsink is 5}00mA This series is offered in 3-pin TO-220 & TO-252 package. Features Standard Application Circuit e Output Voltage Range 5 to 24V Input Output e Output current up to 500mA 7 | OUTS e No external components required . tot ee "02 e Internal thermal overload protection 0.33 uF GND/TAB 0.1uF e Internal short-circuit current limiting LT | e Output transistor safe-area compensation = z om e Output voltage offered in 2% tolerance is A common ground is required between the input and the output voltages. The input voltage must remain typically 2.0V above the output voltage even during the low point on Ordering Information Part No. Package Packing the Input ripple voltage. TS78MxxLACZ CO TO-220 50pcs / Tube XX = these two digits of the type number indicate voltage. TS78MxxLACP RO TO-252 2.5Kpcs / 13 Reel * = Cin is required if regulator is located an appreciable j : distance from power supply filter. Note: Where xx denote voltage option ** = Co is not needed for stability; however, it does improve Available Output Voltage: 05/06/08/09/10/12/15/18/24 transient response. Absolute Maximum Rating (Ta = 25C unless otherwise noted) Parameter Symbol Limit Unit Input Voltage Vin* 35 V Input Voltage Vin** 40 Power Dissipation Pp Internal Limited WwW Operating Junction Temperature Ty 0~+125 C Storage Temperature Range Tste -65~+150 C Note: * TS78MO05LA to TS78M18LA TS78M24LA *** Follow the derating curve 1/10 Version: A07ae lf XL Pb) ROHS ma COMPLIANCE TS78MOOLA Series 3-Terminal 500mA Positive Voltage Regulator TS78MO05LA Electrical Characteristics (Vin=10V, lout=350mA, 0C<Tj<125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 4.90 5 5.10 Output voltage Vout 7.5VsVins20V, Vv 5mAslout<350mMA 4.80 9.20 Line Regulation REGline | Tj=25C }L2VsVins20V = 3 100 8VsVins12V -- 1 50 mV Load Regulation REGload | Tj=25C 2mAsloutss00mA = 15 100 5mAslouts200mMA -- 5 50 Quiescent Current Iq lout=0, Tj=25C - 3 6 7.5VsVins25V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAclout<350mA 05 Output Noise Voltage Vn 10Hz<f<100KHz, Tj=25C -- 40 -- Vv Ripple Rejection Ratio RR f=120Hz, 8V<Vin<s18V 62 78 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- Vv Output Resistance Rout f=1KHz -- 17 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak Tj=25C -- 0.7 -- A Temperature Coefficient of | avout AT) | lout= mA, 0C<T)<125C ~ 0.2 - | mvic Output Voltage TS78MO6LA Electrical Characteristics (Vin=11V, lout=350mA, 0C<Tj<125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 5.88 6 6.12 Output Voltage Vout 8.5VsVins21V, Vv 5mAslout<350mMA 9.76 6 6.24 Line Regulation REGline | Tj=25 |82VsVins20V = 2 120 9V<eVin<13V -- 1.5 60 mV Load Regulation REGload | Tj=25C 2mAsloutss00mA = 14 120 5mAslouts200mMA -- 4 60 Quiescent Current Iq lout=0, Tj=25C -- 3 6 8.5VsVin<s25V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAclout<350mA 05 Output Noise Voltage Vn 10Hz<f<100KHz, Tj=25C -- 45 -- uV Ripple Rejection Ratio RR F=120Hz, 9VsVins19V 59 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- Vv Output Resistance Rout F=1KHz -- 19 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak Tj=25C -- 0.7 -- A Temperature Coefficient of | Vout AT) | lout= SMA, 0C<Tj<125C ~ 0.2 - | mv/c Output Voltage @ Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. @ This specification applies only for DC power dissipation permitted by absolute maximum ratings. 2/10 Version: A07et ar lf XL bb) ROHS to COMPLIANCE TS78MOOLA Series 3-Terminal 500mA Positive Voltage Regulator TS78MO8LA Electrical Characteristics Vin=14V, lout=350mA, 0CsTjs125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 7.84 8 8.16 Output voltage Vout 10.5VsVins23V, Vv 5mAslout<350mMA 7.68 8 8.32 Line Regulation REGline | Tj=25c L02VsWins25V = 6 160 11VsVins17V -- 2 80 mV Load Regulation REGload | Tj=25C -2MAslouts500mA = 12 160 5mAslouts200mMA -- 4 80 Quiescent Current Iq lout=0, Tj=25C - 3 6 10.5VsVins25V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAcloute350mA 05 Output Noise Voltage Vn 10Hz<f<100KHz, Tj=25C -- 52 -- pv Ripple Rejection Ratio RR f=120Hz, 11VsVins21V 56 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- Vv Output Resistance Rout f=1KHz -- 16 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak | Tj=25C - 0.7 - A Temperature Coefficient of | Vout AT; | lout= 5mA, 0C<T}s125C ~ 0.2 - | mvic Output Voltage TS78MO9LA Electrical Characteristics (Vin=15V, lout=350mA, 0C<Tj<s125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 8.82 9 9.18 Output Voltage Vout 11.5VsVins23V, Vv 5mAslout<350mMA 8.64 9 9.36 Line Regulation REGline | Tj=25c LL SVsWins26V = 6 180 12V<Vins17V -- 2 90 mV Load Regulation REGload | Tj=25C RMAslouts500mA = 12 180 5mAslouts200mMA -- 4 90 Quiescent Current Iq lout=0, Tj=25C -- 3 6 11.5VsVins26V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAclout<350mA 05 Output Noise Voltage Vn 10Hz<f<100KHz, Tj=25C -- 52 -- uV Ripple Rejection Ratio RR f=120Hz, 12VsVin<22V 55 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- Vv Output Resistance Rout f=1KHz -- 16 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak Tj=25C -- 0.7 -- A Temperature Coefficient of | Vout) AT; | lout= 5mA, 0C<T}s125C ~ 0.2 - | mvic Output Voltage @ Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. @ This specification applies only for DC power dissipation permitted by absolute maximum ratings. 3/10 Version: A07ae lf XL bb) ROHS to COMPLIANCE TS78MOOLA Series 3-Terminal 500mA Positive Voltage Regulator TS78M12LA Electrical Characteristics (Vin=19V, lout=350mA, 0C<Tj<s125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 11.76 12 12.24 Output Voltage Vout 14.5VsVins27V, V 5mAslout<350mMA 11.52 12 12.48 . . . ._ 5p 0 14.5VsVins30V -- 10 240 Line Regulation REGline Tj=25C 15VeVinel9V ~ 3 120 a . ._ 50 5mAslout<500mMA -- 12 240 Load Regulation REGload | Tj=25C 5mAcloute200mA ~ A 120 Quiescent Current Iq Tj=25C, lout=0 -- 3 6 14.5V<Vins30V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAclout<500MA ~ ~ 05 Output Noise Voltage Vn 10Hz<fs100KHz, Tj=25C -- 75 -- uV Ripple Rejection Ratio RR f=120Hz, 15VsVin<25V 55 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C - 2 - V Output Resistance Rout f=1KHz -- 18 -- mQ Output Short Circuit Current los Tj=25C - 50 - mA Peak Output Current lo peak | Tj=25C - 0.7 - A Temperature Coefficient of | Vout) AT} | lout=5mA, 0CsT}<125C - 0.3 - | mv/c Output Voltage TS78M15LA Electrical Characteristics (Vin=23V, lout=350mA, 0C<Tj<s125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 14.70 15 15.30 Output voltage Vout 17.5VsVins30V, Vv 5mAslout<350mMA 14.40 1S 15.60 Line Regulation REGline | Tj=25 1ZSVsVins30V 12 300 18V<Vin<22V -- 3 150 mV Load Regulation REGload | Tj=25C }2mAsloutss00mA = 12 300 5mAslout<200mMA -- 4 150 Quiescent Current Iq Tj=25C, lout=0 -- 3 6 17.5VsVins30V -- -- 0.8 mA i t tCh Al Quiescent Current Change q 5mAcloute500MA 05 Output Noise Voltage Vn 10Hz<fs100KHz, Tj=25C -- 90 -- wv Ripple Rejection Ratio RR f=120Hz, 18VsVin<28V 54 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C - 2 - V Output Resistance Rout f=1KHz -- 19 -- mQ Output Short Circuit Current los Tj=25C - 50 - mA Peak Output Current lo peak | Tj=25C - 0.7 - A Temperature Coefficientof | AVouy atj | lout=10mA, 0C<T)<125C -- 0.3 -- mvV/ C Output Voltage @ Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. @ This specification applies only for DC power dissipation permitted by absolute maximum ratings. 4/10 Version: A07Sony Pp) ROHS ma COMPLIANCE TS78MOOLA Series 3-Terminal 500mA Positive Voltage Regulator TS78M18LA Electrical Characteristics (Vin=24V, lout=350mA, 0C<Tj<125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 17.64 18 18.36 Output Voltage Vout 21V<Vin<33V, Vv 5mAslouts350mMA 17.28 18 18.72 Line Regulation REGline | Tj=25C -21VsVins33V = 18 360 22V<Vins26V -- 5 180 mV Load Regulation REGload | Tj=25C |2MAsioutss00mA = 12 360 5mAslouts200mMA -- 4 180 Quiescent Current Iq Tj=25C, lout=0 - 3 6 Quiescent Current Change Algq 21VsVins33V 0.8 mA 5mAslouts500mA -- -- 0.5 Output Noise Voltage Vn 10Hz<f<100KHz, Tj=25C -- 110 -- uV Ripple Rejection Ratio RR f=120Hz, 21V<sVin<31V 54 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- V Output Resistance Rout f=1KHz -- 22 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak Tj=25C -- 0.7 -- A Temperature Coefficient of | Vout) AT; | lout= 5mA, 0C<T}s125C ~ 0.5 - | mv/c Output Voltage TS78M24LA Electrical Characteristics Vin=33V, lout=350mA, 0C<Tjs125C, Cin=0.33uF, Cout=0.1uF; unless otherwise specified.) Parameter Symbol Test Condition Min Typ Max Unit Tj=25C 23.52 24 24.48 Output voltage Vout 27VeVins38V, V 5mAclouts350MA 23.07 | 24 | 25.96 . . . . 550 27VsVins38V -- 18 480 Line Regulation REGline Tj=25C 28VeVine32V = 6 40 nV . ._ 5-0 5mAslouts500mMA -- 12 480 Load Regulation REGload | Tj=25C 5mAclout<200mA = A 40 Quiescent Current Iq lout=0, Tj=25C -- 3 6 ; 27VsVins38V -- -- 0.8 mA Quiescent Current Change Alq 5mAclout<500mA 05 Output Noise Voltage Vn 10Hz<fs100KHz, Tj=25C -- 170 -- Vv Ripple Rejection Ratio RR f=120Hz, 27VsVin<37V 54 80 -- dB Voltage Drop Vdrop lout=500mA, Tj=25C -- 2 -- Vv Output Resistance Rout f=1KHz -- 28 -- mQ Output Short Circuit Current los Tj=25C -- 50 -- mA Peak Output Current lo peak Tj=25C -- 0.7 -- A Temperature Coefficient of | avout) AT) | lout= 5mA, 0C<Tj<125C - | 05 - | mvc Output Voltage @ Pulse testing techniques are used to maintain the junction temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. @ This specification applies only for DC power dissipation permitted by absolute maximum ratings. 5/10 Version: A07RoHS COMPLIANCE Electrical Characteristics Curve 1.0 0.9 0.8 0.7 0.6 0.5 0.4 0.3 0.2 0.1 0 Pulse Load Continue Load lout, Output Current (A) 0 5 10 15 20 25 30 Vin, Input Voltage (V) Figure 1. Input Voltage vs. Output Current (max.) 35 40 16 14 12 40 Pulse Load Continue Load Po, Power Dissipation (W) oN BR HO 0 5 10 15 20 25 30 Vin, Input Voltage (V) Figure 3. Input Voltage vs. Power Dissipation 35 40 6.0 co BS o oO ls, Bias Current (mA) NY o 1.0 0 100 200 300 400 500 600 lour, Output Current (A) Figure 5. Bias Current vs. Output Current 700 ~=800 6/10 Vorop, Dropout Voltage (V) Vorop, Dropout Voltage (V) PSRR, Ripple Rejection (dB) TS78MOO0LA Series 3-Terminal 500mA Positive Voltage Regulator 25 22 lo=500mA 1.5 lo=200mA lo=100mA 1.0 lo=10mA 05 0 0 25 50 75 100 125 150 Ts, Junction Temperature (C) Figure 2. Vdrop vs. Junction Temperature 2.5 2.0 1.5 1.0 0.5 0 0 100 200 300 400 500 600 700 800 lour, Output Current (A) Figure 4. Vdrop vs. Output Current 70 65 60 55 50 45 40 35 30 25 0 100 1k Co=0.47uF Co=1uF Co=0.1uF 10k f, Frequency (Hz) 100k Figure 6. Ripple Rejection vs. Frequency Version: A07i S an TS78MO00LA Series (x) RoHS 3-Terminal 500mA Positive Voltage Regulator COMPLIANCE Application information 100 $+ 16 = Mi Poimax) for Ta = 50C 5 os o > 2 90 14 & <9 | | J" a~ | 2.0 oz. Copper a a & 80 ma be L m| f 12 9 wl IC Minimum T H a na oO 1 | c ZF 70 q Size Pad H1.0 Ww t nw L s ZS NJ t 1. we 60 me Hoe & = No 3 $3 50 os 2 3 x ive Roa = 40 | 04 5 0 5.0 10 15 20 25 30 oa L, LENGTH OF COPPER (mm) Figure 7. DPAK Thermal Resistance and Maximum Power Dissipation vs. P.C.B Copper Length 7H0 Version: A07TS78MOOLA Series 3-Terminal 500mA Positive Voltage Regulator SB | (Pr) RoHS - COMPLIANCE \ TO-220 Mechanical Drawing vA ate L TO-220 DIMENSION , _ MILLIMETERS INCHES , o fF P| DIM MIN MAX MIN MAX 4 Pp A 9.31 10.550 0.366 0.415 ' B 3.740 3.910 0.147 0.154 5] C 2.440 2.940 0.096 0.116 J f D 2.22 3.22 0.087 0.127 E 0.78 0.98 0.030 0.038 F 2.34 2.65 0.092 0.104 | G 4.69 5.31 0.184 0.209 tt bee Miu | 14232 | 1388 | 0485 | 0.546 D | 8.74 9.26 0.344 0.364 J 15.07 16.07 0.593 0.632 = K 4.35 4.65 0.171 0.183 H L 1.16 1.40 0.045 0.055 M 27.39 30.35 1.078 1.194 N 1.785 2.675 0.070 0.105 O 1.50 1.75 0.059 0.068 j UJ P 5.75 7.65 0.226 0.301 dj ebelhte OSes F ~e et N ee + G nam Marking Diagram XX = Output Voltage C) (05=5V, 08=8V, 09=9V, 12=12V, 15=15V, 18=18V, 24=24V) Y = Year Code M =Month Code TS/8Mxx (A=Jan, B=Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, IcSep, G5 J=Oct, K=Nov, L=Dec) YML CZ L =Lot Code CZ = Package Code for TO-220 8/10 Version: A07Ee Z TS78MOO0LA Series =n SE oN R HS 3-Terminal 500mA Positive Voltage Regulator (Ph) INO NY compPLiaNce TO-252 Mechanical Drawing D <> TO-252 DIMENSION + | oy |_MILLIMETERS INCHES MIN MAX MIN MAX ( A 2.3BSC 0.09BSC 4 At 4.6BSC 0.18BSC B 6.80 7.20 0.268 0.283 rie Cc 5.40 5.60 0.213 0.220 " D 6.40 6.65 0.252 0.262 t C E 2.20 2.40 0.087 0.094 i} Ley in Vt L F 0.00 0.20 | 0.000 | 0.008 pl ile |i 7, a _Y- G 5.20 5.40 0.205 | 0.213 G1 i a >| <_H es G1 0.75 0.85 0.030 0.033 { G2 | |< I G2 0.55 0.65 0.022 0.026 H 0.35 0.65 0.014 0.026 ( ) A 0.90 1.50 0.035 0.059 {jt 2 J 2.20 2.80 0.087 0.110 F t | i ; K 0.50 1.10 0.020 0.043 r 4 5 > L 0.90 1.50 0.035 0.059 A : M 1.30 1.70 0.051 0.67 <______ >: Al Marking Diagram ( ) XX = Output Voltage 78M (05=5V, 08=8V, 09=9V, 12=12V, 15=15V, 18=18V, 24=24V) XX Y = Year Code G5 M =Month Code YML. CP (A=Jan, B=Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, I=-Sep, J=Oct, K=Nov, L=Dec) H LJ H L = Lot Code CP = Package Code for TO-252 9/10 Version: AO7Ob Loe TS78MOO0LA Series (Pp) RoHS 3-Terminal 500mA Positive Voltage Regulator @& COMPLIANCE Notice Specifications of the products displayed herein are subject to change without notice. TSC or anyone on its behalf, assumes no responsibility or liability for any errors or inaccuracies. Information contained herein is intended to provide a product description only. No license, express or implied, to any intellectual property rights is granted by this document. Except as provided in TSCs terms and conditions of sale for such products, TSC assumes no liability whatsoever, and disclaims any express or implied warranty, relating to sale and/or use of TSC products including liability or warranties relating to fitness for a particular purpose, merchantability, or infringement of any patent, copyright, or other intellectual property right. The products shown herein are not designed for use in medical, life-saving, or life-sustaining applications. Customers using or selling these products for use in such applications do so at their own risk and agree to fully indemnify TSC for any damages resulting from such improper use or sale. 10/10 Version: AO7