ILLUMINATION
No. E352519
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet ©2016 Lumileds Holding B.V. All rights reserved.
FEATURES AND BENEFITS PRIMARY APPLICATIONS
Highest ux densities with industry’s smallest LES Architectural
3-step MacAdam ellipse color denition: Freedom from Binning for color
consistency from luminaire to luminaire Downlights
Up to 4x lower thermal resistance than competition, enabling smaller heat
sinks and higher lumens High Bay & Low Bay
Supported by a comprehensive optical, mechanical and electrical ecosystem Lamps
Outdoor
Specialty Lighting
Spotlights
The second generation of LUXEON CoB represents a new breakthrough
in ecacy for arrays. It has 10% higher eciency and 10% higher lumen
output at the same drive currents as existing LUXEON CoB. Due to its
small Light Emitting Surface (LES) and industry-leading thermal resistance,
LUXEON CoB is easy to work with, enabling simplied and less expensive
luminaire designs. LUXEON CoBs are hot-tested at 85°C—real world
operating conditions—which means additional testing can be minimized.
LUXEON CoB LEDs are available in 3-step MacAdam ellipse, ensuring
uniform optical performance in a wide range of applications.
LUXEON CoB Core Range (Gen 2)
Uniform, high-ecacy and easy-to-design array
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. i
Table of Contents
General Product Information ......................................................................2
Product Test Conditions ..............................................................................2
Part Number Nomenclature ..........................................................................2
Lumen Maintenance .................................................................................2
Environmental Compliance ...........................................................................2
Performance Characteristics ......................................................................3
Product Selection Guide..............................................................................3
Optical Characteristics ...............................................................................7
Electrical and Thermal Characteristics..................................................................7
Absolute Maximum Ratings .......................................................................7
Characteristic Curves .............................................................................8
Spectral Power Distribution Characteristics .............................................................8
Light Output Characteristics ..........................................................................9
Forward Current Characteristics......................................................................13
Radiation Pattern Characteristics .....................................................................17
Color Bin Denition .................................................................................18
Mechanical Dimensions..........................................................................19
Package and Labeling Information ................................................................23
Total Units per Tube ................................................................................23
Tube Dimensions ..................................................................................23
Tube Label.........................................................................................24
Inner Box..........................................................................................25
Outer Box .........................................................................................26
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 2
General Product Information
Product Test Conditions
LUXEON CoB Core Range (Gen 2) LEDs are tested and binned with a DC drive current specied below at a junction temperature,
Tj, of 85°C:
200mA – LUXEON CoB 1202s
200mA – LUXEON CoB 1202
300mA – LUXEON CoB 1203
450mA – LUXEON CoB 1204
600mA – LUXEON CoB 1205
900mA – LUXEON CoB 1208
1200mA – LUXEON CoB 1211
1600mA – LUXEON CoB 1216
Part Number Nomenclature
Part numbers for LUXEON CoB Core Range (Gen 2) follow the convention below:
L 2 C 2 – A A B B C C C C E D D F F
Where:
A A – designates nominal CCT (22=2200K, 27=2700K, 30=3000K, 35=3500K, 40=4000K,
50=5000K, 57=5700K)
B B – designates minimum CRI (70=70CRI, 80=80CRI, 90=90CRI)
C C C C – designates product conguration (example: 1202, 1203, 1204, 1205, 1208, 1211, 1216)
D D – designates light emitting surface (LES) size (06=6mm, 09=9mm, 13=13mm, 15=15mm, 19=19mm, 23=23mm)
F F – designates options for product specication
Therefore, the following part number is used for a LUXEON CoB Core Range (Gen 2) 1203, 3000K 80CRI, 9mm LES:
L 2 C 2 – 3 0 8 0 1 2 0 3 E 0 9 0 0
Lumen Maintenance
Please contact your local Sales Representative or Lumileds Technical Solutions Manager for more information about the
long-term performance of this product.
Environmental Compliance
Lumileds LLC is committed to providing environmentally friendly products to the solid-state lighting market. LUXEON CoB Core
Range (Gen 2) is compliant to the European Union directives on the restriction of hazardous substances in electronic equipment,
namely the RoHS Directive 2011/65/EU and REACH Regulation (EC) 1907/2006. Lumileds LLC will not intentionally add the
following restricted materials to its products: lead, mercury, cadmium, hexavalent chromium, polybrominated biphenyls (PBB) or
polybrominated diphenyl ethers (PBDE).
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 3
Performance Characteristics
Product Selection Guide
Table 1. Product performance of LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85ºC.
PRODUCT NOMINAL
CCT
MINIMUM
CRI [1, 2, 3]
LUMINOUS FLUX [1] (lm)TYPICAL
LUMINOUS
EFFICACY (lm/W)
TEST
CURRENT
(mA)
LES
(mm)PART NUMBER
MINIMUM TYPICAL
LUXEON
CoB
1202s
2200K 80 660 733 105 200 6.5 L2C2-22801202E0600
2700K 80 756 840 120 200 6.5 L2C2-27801202E0600
3000K 80 788 875 125 200 6.5 L2C2-30801202E0600
3500K 80 828 920 131 200 6.5 L2C2-35801202E0600
4000K 80 844 938 134 200 6.5 L2C2-40801202E0600
5000K 80 860 956 137 200 6.5 L2C2-50801202E0600
5700K 80 828 920 131 200 6.5 L2C2-57801202E0600
2200K 90 573 636 91 200 6.5 L2C2-22901202E0600
2200K 90 [4] 539 599 86 200 6.5 L2C2-22951202E0600
2700K 90 661 734 105 200 6.5 L2C2-27901202E0600
2700K 90 [4] 609 677 97 200 6.5 L2C2-27951202E0600
3000K 90 675 750 107 200 6.5 L2C2-30901202E0600
3000K 90 [4] 637 708 101 200 6.5 L2C2-30951202E0600
3500K 90 708 786 112 200 6.5 L2C2-35901202E0600
3500K 90 [4] 662 735 105 200 6.5 L2C2-35951202E0600
4000K 90 720 800 114 200 6.5 L2C2-40901202E0600
4000K 90 [4] 700 778 111 200 6.5 L2C2-40951202E0600
LUXEON
CoB
1202
3000K 70 924 1027 147 200 9 L2C2-30701202E0900
3500K 70 924 1027 147 200 9 L2C2-35701202E0900
4000K 70 982 1092 152 200 9 L2C2-40701202E0900
5000K 70 982 1092 152 200 9 L2C2-50701202E0900
5700K 70 941 1045 149 200 9 L2C2-57701202E0900
2200K 80 658 731 104 200 9 L2C2-22801202E0900
2700K 80 791 879 126 200 9 L2C2-27801202E0900
3000K 80 833 925 132 200 9 L2C2-30801202E0900
3500K 80 866 962 137 200 9 L2C2-35801202E0900
4000K 80 895 994 142 200 9 L2C2-40801202E0900
5000K 80 899 999 143 200 9 L2C2-50801202E0900
5700K 80 859 955 134 200 9 L2C2-57801202E0900
2200K 90 599 666 95 200 9 L2C2-22901202E0900
2700K 90 691 768 110 200 9 L2C2-27901202E0900
3000K 90 716 796 114 200 9 L2C2-30901202E0900
3500K 90 740 822 118 200 9 L2C2-35901202E0900
4000K 90 774 860 123 200 9 L2C2-40901202E0900
Table 1 continued on next page.
1. Lumileds maintains a tolerance of ±2 on CRI and ±6.5% on luminous ux measurements.
2. Typical CRI is approximately 2 points higher than the minimum CRI specied, but this is not guaranteed.
3. R9 value of 90CRI products is >50.
4. Typical CRI is 97.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 4
Table 1. Product performance of LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85ºC (continued).
PRODUCT NOMINAL
CCT
MINIMUM
CRI [1, 2, 3]
LUMINOUS FLUX [1] (lm)TYPICAL
LUMINOUS
EFFICACY (lm/W)
TEST
CURRENT
(mA)
LES
(mm)PART NUMBER
MINIMUM TYPICAL
LUXEON
CoB
1203
3000K 70 1332 1499 143 300 9 L2C2-30701203E0900
3500K 70 1332 1499 143 300 9 L2C2-35701203E0900
4000K 70 1416 1593 148 300 9 L2C2-40701203E0900
5000K 70 1416 1593 148 300 9 L2C2-50701203E0900
5700K 70 1356 1526 145 300 9 L2C2-57701203E0900
2200K 80 948 1067 102 300 9 L2C2-22801203E0900
2700K 80 1140 1283 122 300 9 L2C2-27801203E0900
3000K 80 1200 1350 129 300 9 L2C2-30801203E0900
3500K 80 1248 1404 134 300 9 L2C2-35801203E0900
4000K 80 1290 1451 138 300 9 L2C2-40801203E0900
5000K 80 1296 1458 139 300 9 L2C2-50801203E0900
5700K 80 1264 1404 134 300 9 L2C2-57801203E0900
2200K 90 864 972 93 300 9 L2C2-22901203E0900
2700K 90 996 1121 107 300 9 L2C2-27901203E0900
3000K 90 1032 1161 111 300 9 L2C2-30901203E0900
3500K 90 1067 1200 114 300 9 L2C2-35901203E0900
4000K 90 1116 1256 120 300 9 L2C2-40901203E0900
LUXEON
CoB
1204
3000K 70 1998 2248 143 450 13 L2C2-30701204E1300
3500K 70 1998 2248 143 450 13 L2C2-35701204E1300
4000K 70 2124 2390 148 450 13 L2C2-40701204E1300
5000K 70 2124 2390 148 450 13 L2C2-50701204E1300
5700K 70 2034 2288 145 450 13 L2C2-57701204E1300
2200K 80 1422 1600 102 450 13 L2C2-22801204E1300
2700K 80 1710 1924 122 450 13 L2C2-27801204E1300
3000K 80 1800 2025 129 450 13 L2C2-30801204E1300
3500K 80 1872 2106 134 450 13 L2C2-35801204E1300
4000K 80 1935 2177 138 450 13 L2C2-40801204E1300
5000K 80 1944 2187 139 450 13 L2C2-50801204E1300
5700K 80 1971 2190 134 450 13 L2C2-57801204E1300
2200K 90 1296 1458 93 450 13 L2C2-22901204E1300
2700K 90 1494 1681 107 450 13 L2C2-27901204E1300
3000K 90 1548 1742 111 450 13 L2C2-30901204E1300
3500K 90 1600 1800 114 450 13 L2C2-35901204E1300
4000K 90 1674 1883 120 450 13 L2C2-40901204E1300
Table 1 continued on next page.
1. Lumileds maintains a tolerance of ±2 on CRI and ±6.5% on luminous ux measurements.
2. Typical CRI is approximately 2 points higher than the minimum CRI specied, but this is not guaranteed.
3. R9 value of 90CRI products is >50.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 5
Table 1. Product performance of LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85ºC (continued).
PRODUCT NOMINAL
CCT
MINIMUM
CRI [1, 2, 3]
LUMINOUS FLUX [1] (lm)TYPICAL
LUMINOUS
EFFICACY (lm/W)
TEST
CURRENT
(mA)
LES
(mm)PART NUMBER
MINIMUM TYPICAL
LUXEON
CoB
1205
3000K 70 2720 2997 143 600 13 L2C2-30701205E1300
3500K 70 2720 2997 143 600 13 L2C2-35701205E1300
4000K 70 2891 3186 148 600 13 L2C2-40701205E1300
5000K 70 2891 3186 148 600 13 L2C2-50701205E1300
5700K 70 2769 3051 145 600 13 L2C2-57701205E1300
2200K 80 1936 2133 102 600 13 L2C2-22801205E1300
2700K 80 2328 2565 122 600 13 L2C2-27801205E1300
3000K 80 2450 2700 129 600 13 L2C2-30801205E1300
3500K 80 2548 2808 134 600 13 L2C2-35801205E1300
4000K 80 2634 2903 138 600 13 L2C2-40801205E1300
5000K 80 2646 2916 139 600 13 L2C2-50801205E1300
5700K 80 2527 2808 134 600 13 L2C2-57801205E1300
2200K 90 1764 1944 93 600 13 L2C2-22901205E1300
2700K 90 2034 2241 107 600 13 L2C2-27901205E1300
3000K 90 2107 2322 111 600 13 L2C2-30901205E1300
3500K 90 2178 2400 114 600 13 L2C2-35901205E1300
4000K 90 2279 2511 120 600 13 L2C2-40901205E1300
LUXEON
CoB
1208
3000K 70 4024 4496 143 900 15 L2C2-30701208E1500
3500K 70 4024 4496 143 900 15 L2C2-35701208E1500
4000K 70 4278 4779 148 900 15 L2C2-40701208E1500
5000K 70 4278 4779 148 900 15 L2C2-50701208E1500
5700K 70 4096 4577 145 900 15 L2C2-57701208E1500
2200K 80 2864 3200 102 900 15 L2C2-22801208E1500
2700K 80 3444 3848 122 900 15 L2C2-27801208E1500
3000K 80 3625 4050 129 900 15 L2C2-30801208E1500
3500K 80 3770 4212 134 900 15 L2C2-35801208E1500
4000K 80 3897 4354 138 900 15 L2C2-40801208E1500
5000K 80 3915 4374 139 900 15 L2C2-50801208E1500
5700K 80 3791 4212 134 900 15 L2C2-57801208E1500
2200K 90 2610 2916 93 900 15 L2C2-22901208E1500
2700K 90 3009 3362 107 900 15 L2C2-27901208E1500
3000K 90 3118 3483 111 900 15 L2C2-30901208E1500
3500K 90 3223 3600 114 900 15 L2C2-35901208E1500
4000K 90 3371 3767 120 900 15 L2C2-40901208E1500
Table 1 continued on next page.
1. Lumileds maintains a tolerance of ±2 on CRI and ±6.5% on luminous ux measurements.
2. Typical CRI is approximately 2 points higher than the minimum CRI specied, but this is not guaranteed.
3. R9 value of 90CRI products is >50.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 6
Table 1. Product performance of LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85ºC (continued).
PRODUCT NOMINAL
CCT
MINIMUM
CRI [1, 2, 3]
LUMINOUS FLUX [1] (lm)TYPICAL
LUMINOUS
EFFICACY (lm/W)
TEST
CURRENT
(mA)
LES
(mm)PART NUMBER
MINIMUM TYPICAL
LUXEON
CoB
1211
3000K 70 5550 5994 143 1200 19 L2C2-30701211E1900
3500K 70 5550 5994 143 1200 19 L2C2-35701211E1900
4000K 70 5900 6372 148 1200 19 L2C2-40701211E1900
5000K 70 5900 6372 148 1200 19 L2C2-50701211E1900
5700K 70 5650 6102 145 1200 19 L2C2-57701211E1900
2200K 80 3950 4266 102 1200 19 L2C2-22801211E1900
2700K 80 4750 5130 122 1200 19 L2C2-27801211E1900
3000K 80 5000 5400 129 1200 19 L2C2-30801211E1900
3500K 80 5200 5616 134 1200 19 L2C2-35801211E1900
4000K 80 5375 5805 138 1200 19 L2C2-40801211E1900
5000K 80 5400 5832 139 1200 19 L2C2-50801211E1900
5700K 80 5054 5616 134 1200 19 L2C2-57801211E1900
2200K 90 3600 3888 93 1200 19 L2C2-22901211E1900
2700K 90 4150 4482 107 1200 19 L2C2-27901211E1900
3000K 90 4300 4644 111 1200 19 L2C2-30901211E1900
3500K 90 4445 4801 114 1200 19 L2C2-35901211E1900
4000K 90 4650 5022 120 1200 19 L2C2-40901211E1900
LUXEON
CoB
1216
3000K 70 7229 8032 143 1600 23 L2C2-30701216E2300
3500K 70 7229 8032 143 1600 23 L2C2-35701216E2300
4000K 70 7684 8538 152 1600 23 L2C2-40701216E2300
5000K 70 7684 8538 152 1600 23 L2C2-50701216E2300
5700K 70 7359 8177 146 1600 23 L2C2-57701216E2300
2200K 80 5144 5716 102 1600 23 L2C2-22801216E2300
2700K 80 6187 6874 123 1600 23 L2C2-27801216E2300
3000K 80 6512 7236 129 1600 23 L2C2-30801216E2300
3500K 80 6773 7525 134 1600 23 L2C2-35801216E2300
4000K 80 7002 7780 139 1600 23 L2C2-40801216E2300
5000K 80 7034 7815 140 1600 23 L2C2-50801216E2300
5700K 80 6773 7525 134 1600 23 L2C2-57801216E2300
2200K 90 4689 5210 93 1600 23 L2C2-22901216E2300
2700K 90 5405 6006 107 1600 23 L2C2-27901216E2300
3000K 90 5601 6223 111 1600 23 L2C2-30901216E2300
3500K 90 5790 6433 115 1600 23 L2C2-35901216E2300
4000K 90 6056 6729 120 1600 23 L2C2-40901216E2300
Notes for Table 1:
1. Lumileds maintains a tolerance of ±2 on CRI and ±6.5% on luminous ux measurements.
2. Typical CRI is approximately 2 points higher than the minimum CRI specied, but this is not guaranteed.
3. R9 value of 90CRI products is >50.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 7
Optical Characteristics
Table 2. Optical characteristics for LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85°C.
PART NUMBER TYPICAL TOTAL INCLUDED ANGLE [1] TYPICAL VIEWING ANGLE [2]
L2C2-xxxx12xxExx00 135° 115°
Notes for Table 2:
1. Total angle at which 90% of total luminous ux is captured.
2. Viewing angle is the o axis angle from the LED centerline where the luminous intensity is ½ of the peak value.
Electrical and Thermal Characteristics
Table 3. Electrical and thermal characteristics for LUXEON CoB Core Range (Gen 2) at specied test current, Tj=85°C.
PART NUMBER
FORWARD VOLTAGE [1] (V) TYPICAL TEMPERATURE
COEFFICIENT OF FORWARD
VOLTAGE [2] (mV/°C)
TYPICAL THERMAL
RESISTANCE JUNCTION TO
SOLDER PAD [3] (°C/W)
MINIMUM TYPICAL MAXIMUM
L2C2-XXXX1202E0600 32.5 34.5 37.5 -16 0.98
L2C2-xxxx1202E0900 32.5 34.5 37.5 -16 0.98
L2C2-xxxx1203E0900 32.5 34.5 37.5 -16 0.70
L2C2-xxxx1204E1300 32.5 35.0 37.5 -16 0.55
L2C2-xxxx1205E1300 32.5 35.0 37.5 -16 0.51
L2C2-xxxx1208E1500 32.5 35.0 37.5 -16 0.29
L2C2-xxxx1211E1900 32.5 35.0 37.5 -16 0.23
L2C2-xxxx1216E2300 32.5 35.0 37.5 -16 0.14
Notes for Table 3:
1. Lumileds maintains a tolerance of ±2% on forward voltage measurements.
2. Measured between 25°C and 85°C.
3. Thermal resistance is measured between junction and the bottom of the LUXEON CoB substrate.
Absolute Maximum Ratings
Table 4. Absolute maximum ratings for LUXEON CoB Core Range (Gen 2).
PARAMETER MAXIMUM PERFORMANCE
DC Forward Current [1, 2] 2x test current
LED Junction Temperature [1] (DC & Pulse) 125°C
ESD Sensitivity (ANSI/ESDA/JEDEC JS-001-2012) Class 3B
Operating Case Temperature [1] -40°C to 105°C
LED Storage Temperature -40°C to 120°C
Allowable Reow Cycles 3
Reverse Voltage (Vreverse) LUXEON LEDs are not designed to be driven in reverse bias
Notes for Table 4:
1. Proper current derating must be observed to maintain the junction temperature below the maximum allowable junction temperature.
2. Residual periodic variations due to power conversion from alternating current (AC) to direct current (DC), also called “ripple,” are acceptable if the following conditions are met:
– The frequency of the ripple current is 100Hz or higher
– The average current for each cycle does not exceed the maximum allowable DC forward current
– The maximum amplitude of the ripple does not exceed 20% of the maximum allowable DC forward current
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 8
Characteristic Curves
Spectral Power Distribution Characteristics
Figure 1a: Typical normalized power vs. wavelength for L2C2-xx70xxxxExx00 at specied test current, Tj=85°C.
Figure 1b: Typical normalized power vs. wavelength for L2C2-xx80xxxxExx00 at specied test current, Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 9
Light Output Characteristics
Figure 2: Typical normalized light output vs. junction temperature for L2C2-xxxxxxxxExx00 at specied test current.
Figure 1c: Typical normalized power vs. wavelength for L2C2-xx90xxxxExx00 at specied test current, Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 10
Figure 3b: Typical normalized light output vs. forward current forL2C2-xxxx1203E0900 at Tj=85°C.
Figure 3a: Typical normalized light output vs. forward current for L2C2-XXXX1202E0600 and L2C2-xxxx1202E0900 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 11
Figure 3d: Typical normalized light output vs. forward current for L2C2-xxxx1205E1300 at Tj=85°C.
Figure 3c: Typical normalized light output vs. forward current for L2C2-xxxx1204E1300 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 12
Figure 3f: Typical normalized light output vs. forward current for L2C2-xxxx1211E1900 at Tj=85°C.
Figure 3e: Typical normalized light output vs. forward current for L2C2-xxxx1208E1500 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 13
Forward Current Characteristics
Figure 4a: Typical forward current vs. forward voltage for L2C2-XXXX1202E0600 and L2C2-xxxx1202E0900 at Tj=85°C.
Figure 3g: Typical normalized light output vs. forward current for L2C2-xxxx1216E2300 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 14
Figure 4c: Typical forward current vs. forward voltage for L2C2-xxxx1204E1300 at Tj=85°C.
Figure 4b: Typical forward current vs. forward voltage for L2C2-xxxx1203E0900 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 15
Figure 4e: Typical forward current vs. forward voltage for L2C2-xxxx1208E1500 at Tj=85°C.
Figure 4d: Typical forward current vs. forward voltage for L2C2-xxxx1205E1300 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 16
Figure 4g: Typical forward current vs. forward voltage for L2C2-xxxx1216E2300 at Tj=85°C.
Figure 4f: Typical forward current vs. forward voltage for L2C2-xxxx1211E1900 at Tj=85°C.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 17
Radiation Pattern Characteristics
Figure 5: Typical radiation pattern for L2C2-xxxxxxxxExx00 at specied test current, Tj=85ºC.
Figure 6: Typical polar radiation pattern for L2C2-xxxxxxxxExx00 at specied test current, Tj=85ºC.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 18
Color Bin Denition
Table 5. 3-step MacAdam ellipse color bin denitions for LUXEON CoB Core Range (Gen 2).
NOMINAL CCT COLOR SPACE CENTER POINT
(cx, cy)
MAJOR AXIS,
a
MINOR AXIS,
b
ELLIPSE ROTATION
ANGLE, θ
2200K Single 3-step MacAdam ellipse (0.5020, 0.4155) 0.00862 0.00397 49.30°
2700K Single 3-step MacAdam ellipse (0.4578, 0.4101) 0.00810 0.00420 53.70°
3000K Single 3-step MacAdam ellipse (0.4338, 0.4030) 0.00834 0.00408 53.20°
3500K Single 3-step MacAdam ellipse (0.4073, 0.3917) 0.00927 0.00414 54.00°
4000K Single 3-step MacAdam ellipse (0.3818, 0.3797) 0.00939 0.00402 53.70°
5000K Single 3-step MacAdam ellipse (0.3447, 0.3553) 0.00822 0.00354 59.60°
5700K Single 3-step MacAdam ellipse (0.3287, 0.3417) 0.00745 0.00320 59.09°
Notes for Table 5:
1. Lumileds maintains a tolerance of ±0.005 on x and y coordinates in the CIE 1931 color space.
Figure 7: 3-step MacAdam ellipse illustration for Table 5.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 19
Mechanical Dimensions
Notes for Figures 8a and 8b:
1. Drawings not to scale.
2. All dimensions are in millimeters.
Figure 8a. Mechanical dimensions for L2C2-XXXX1202E0600.
Figure 8b. Mechanical dimensions for L2C2-xxxx1202E0900.
C
L
0.1
1±0.1
0.5±0.2
C
L
C
L
6
3.5
6.5
6
6.5
2
3.5
2
3.5
3.5
2x 16±0.2
19±0.2
R1.6
11.3±0.3
2
9+
-
0.5
0.1
° DIMENSIONS ARE IN MILLIMETERS
DRAW IN G
DO NOT SCALE THIS
METRIC
B
° THIRD ANGLE PROJECTION
COB DATASHEET
DRAWING
XX.X ±0.1 mm XX.X ±0°30'
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
2013-01-24
5:111
16x19 LES9
2013-01-24T. VU
DRAWN BYDATE
ENGINEER/CHECKER
TITLE
SCALESHEET
OF
XX.XX ±0.05 mm XX.XX ±0°00'30"
T. VU / R. HELBING
FRAME DATE: 2011- 04-1 8
UNLESS OTHERW ISE SPECIFIED
DATE
LINEAR: ANGULAR:
XX. ±0.2 mm XX ±1°
TOLERANCES
(UNLESS OTHERWISE SPECIFIED)
L2C2-xxxx1202E0900
AABBF1202
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 20
Notes for Figures 8c and 8d:
1. Drawings not to scale.
2. All dimensions are in millimeters.
Figure 8c. Mechanical dimensions for L2C2-xxxx1203E0900.
Figure 8d. Mechanical dimensions for L2C2-xxxx1204E1300.
C
L
C
L
4.5
24±0.2
3.5
4.5
2x
R1.6
15.5±0.3
2
8
3.5
8
2
20±0.2
8.5
7.5
2
13+
-
0.5
0.1
C
L
0.1
1±0.1
0.5±0.2
L2C2-xxxx1204E1300 L2C2-xxxx1205E1300
C
L
0.1
1±0.1
0.5±0.2
C
L
C
L
4.5
24±0.2
3.5 4.5
2x
R1.6
15.5±0.3
2
8
3.5
8
2
20±0.2
8.5
7.5
2
13+
-
0.5
0.1
B
° THIRD ANGLE PROJECTION
COB DATASHEET
DRAWING
XX.X ±0.1 mm XX.X ±0°30'
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
2013-01-24
5:111
20x24 LES13
2013-01-24T. VU
T. VU / R. HELBING
DATE
FRAME DATE: 2011- 04-18
DRAWN BY
SCALESHEET
OF
XX.XX ±0.05 mm XX.XX ±0°00'30"
UNLESS OTHERW ISE SPECIFIED
° DIMENSIONS ARE IN MILLIMETERS
DRAW IN G
DATE
TITLE
METRIC
ENGINEER/CHECKER
DO NOT SCALE THIS
LINEAR: ANGULAR:
XX. ±0.2 mm XX ±1°
TOLERANCES
(UNLESS OTHERWISE SPECIFIED)
AABBF1205
AABBF1204
C
L
0.1
1±0.1
0.5±0.2
C
L
C
L
6
3.5
6.5
6
6.5
2
3.5
2
3.5
3.5
2x 16±0.2
19±0.2
R1.6
11.3±0.3
2
9+
-
0.5
0.1
° DIMENSIONS ARE IN MILLIMETERS
DRAW IN G
DO NOT SCALE THIS
METRIC
B
° THIRD ANGLE PROJECTION
COB DATASHEET
DRAWING
XX.X ±0.1 mm XX.X ±0°30'
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
2013-01-24
5:111
16x19 LES9
2013-01-24T. VU
DRAWN BYDATE
ENGINEER/CHECKER
TITLE
SCALESHEET
OF
XX.XX ±0.05 mm XX.XX ±0°00'30"
T. VU / R. HELBING
FRAME DATE: 2011- 04-1 8
UNLESS OTHERW ISE SPECIFIED
DATE
LINEAR: ANGULAR:
XX. ±0.2 mm XX ±1°
TOLERANCES
(UNLESS OTHERWISE SPECIFIED)
L2C2-xxxx1203E0900
AABBF1203
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 21
Notes for Figures 8e and 8f:
1. Drawings not to scale.
2. All dimensions are in millimeters.
Figure 8e. Mechanical dimensions for L2C2-xxxx1205E1300.
Figure 8f. Mechanical dimensions for L2C2-xxxx1208E1500.
C
L
C
L
17.5±0.3
2
2x
2
8
4.5
2
8
3.5 4.5
24±0.2
7.5
8.5
20±0.2
R1.6
3.5
15+
-
0.5
0.1
C
L
0.1
1±0.1
0.5±0.2
DRAWING
XX.X ±0.1 mm XX.X ±0°30'
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
2013-01-24
5:111
20x24 LES15
2013-01-24T. VU
T. VU / R. HELBING
DATE
FRAME DATE: 2011- 04-18
DRAWN BYDATE
ENGINEER/CHECKER
TITLE
XX.XX ±0.05 mm XX.XX ±0°00'30"
UNLESS OTHERW ISE SPECIFIED
° DIMENSIONS ARE IN MILLIMETERS
DRAW IN G
DO NOT SCALE THIS
METRIC
B
SCALE
OF
COB DATASHEET
SHEET
° THIRD ANGLE PROJECTION
LINEAR: ANGULAR:
XX. ±0.2 mm XX ±1°
TOLERANCES
(UNLESS OTHERWISE SPECIFIED)
L2C2-xxxx1208E1500
AABBF1208
C
L
C
L
4.5
24±0.2
3.5
4.5
2x
R1.6
15.5±0.3
2
8
3.5
8
2
20±0.2
8.5
7.5
2
13+
-
0.5
0.1
C
L
0.1
1±0.1
0.5±0.2
L2C2-xxxx1204E1300 L2C2-xxxx1205E1300
C
L
0.1
1±0.1
0.5±0.2
C
L
C
L
4.5
24±0.2
3.5 4.5
2x
R1.6
15.5±0.3
2
8
3.5
8
2
20±0.2
8.5
7.5
2
13+
-
0.5
0.1
B
° THIRD ANGLE PROJECTION
COB DATASHEET
DRAWING
XX.X ±0.1 mm XX.X ±0°30'
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
2013-01-24
5:111
20x24 LES13
2013-01-24T. VU
T. VU / R. HELBING
DATE
FRAME DATE: 2011- 04-18
DRAWN BY
SCALESHEET
OF
XX.XX ±0.05 mm XX.XX ±0°00'30"
UNLESS OTHERW ISE SPECIFIED
° DIMENSIONS ARE IN MILLIMETERS
DRAW IN G
DATE
TITLE
METRIC
ENGINEER/CHECKER
DO NOT SCALE THIS
LINEAR: ANGULAR:
XX. ±0.2 mm XX ±1°
TOLERANCES
(UNLESS OTHERWISE SPECIFIED)
AABBF1205
AABBF1204
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 22
Notes for Figures 8g and 8h:
1. Drawings not to scale.
2. All dimensions are in millimeters.
Figure 8g. Mechanical dimensions for L2C2-xxxx1211E1900.
2X
2
12
C
L
C
L
C
L
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
1/20/14
4:1
11
28X28 LES19
1/20/14
MMW
RENE/THUY
DATE
FRAME DATE: 2013-05-10
DRAWN BY
DATE
ENGINEER/CHECKER
TITLE
SCALESHEET
OF
UNLESS OTHERWISE SPECIFIED
° DIMENSIONS ARE IN MILLIMETERS
DRAWING
DO NOT SCALE THIS
METRIC
B
° THIRD ANGLE PROJECTION
COB DATA SHEET
DRAWING
TOLERANCES
MATERIAL FINISH
- -
AABBF1211
L2C2-xxxx1211E1900
Figure 8h. Mechanical dimensions for L2C2-xxxx1216E2300.
2X
2
C
LC
L
C
L
YYYY-MM-DD
PER
GD&T SYMBOLOGY
ASME Y14.5M-1994
SIZE
7/8/14
4:1
11
28X28 LES23
7/8/14
MMW
RENE/THUY
DATE
FRAME DATE: 2013-05-10
DRAWN BY
DATE
ENGINEER/CHECKER
TITLE
SCALESHEET
OF
UNLESS OTHERWISE SPECIFIED
° DIMENSIONS ARE IN MILLIMETERS
DRAWING
DO NOT SCALE THIS
METRIC
B
° THIRD ANGLE PROJECTION
COB DATA SHEET
DRAWING
TOLERANCES
MATERIAL FINISH
- -
L2C2-xxxx-1216E2300
AABBF1216
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 23
Package and Labeling Information
LUXEON CoB LEDs are packaged in tubes then in a carton box. Each tube contains a specied number of LEDs. The LEDs in each
tube come from a single category code, ensuring they are all well-matched for light output, color, and forward voltage. Each tube
contains a rubber stopper at one end. The tube label has both alphanumeric and bar code information. The carton boxes have
printed information providing part numbers with CAT codes that indicate luminous ux, color and forward voltage bins.
Total Units per Tube
Table 6. Number of LEDs per tube for LUXEON CoB Core Range (Gen2).
PART NUMBER TOTAL UNITS PER TUBE TOTAL TUBES PER INNERBOX TOTAL UNITS PER INNERBOX
L2C2-XXXX1202E0600 20 5 100
L2C2-xxxx1202E0900 20 5 100
L2C2-xxxx1203E0900 20 5 100
L2C2-xxxx1204E1300 20 5 100
L2C2-xxxx1205E1300 20 5 100
L2C2-xxxx1208E1500 20 5 100
L2C2-xxxx1211E1900 10 5 50
L2C2-xxxx1216E2300 10 5 50
Tube Dimensions
Notes for Figure 9:
1. Drawings are not to scale.
2. All dimensions are in millimeters.
Figure 9a: Tube dimensions for L2C2-XXXX1202E0600.
Figure 9b: Tube dimensions for L2C2-xxxxxxxxE0900.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 24
Notes for Figure 9:
1. Drawings are not to scale.
2. All dimensions are in millimeters.
Tube Label
Table 7. Label information for LUXEON CoB Core Range (Gen2).
ITEM INFORMATION
(1P) Part Number
Lot Number
CAT Code
Tube Quantity
Manufacturing date code
Serial Number
Figure 9c: Tube dimensions for L2C2-xxxx1204E1300, L2C2-xxxx1205E1300 and L2C2-xxxx1208E1500.
Figure 9d: Tube dimensions for L2C2-xxxx1211E1900.
Figure 10: Example of a tube label.
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 25
Inner Box
Table 8. Inner box information for LUXEON CoB Core Range (Gen2).
BOX TYPE DIMENSIONS (mm)AVERAGE WEIGHT
(100pcs/box)
AVERAGE WEIGHT
(100pcs/box)
H L W
Inner Box 30 490 95 0.340Kg 0.305Kg
Figure 11: Dimensions for inner box packaging.
Figure 12: Example of inner box label for LUXEON CoB Core Range (Gen2).
DS155 LUXEON CoB Core Range (Gen 2) Product Datasheet 20161105 ©2016 Lumileds Holding B.V. All rights reserved. 26
Outer Box
Table 9. Outer box information for LUXEON CoB Core Range (Gen2).
BOX TYPE
DIMENSIONS (mm)MAXIMUM
INNER BOX
PER OUTER BOX
MAXIMUM QUANTITY
PER OUTER BOX
AVERAGE WEIGHT
(100pcs/box)
AVERAGE WEIGHT
(50pcs/box)
H L W
Outer Box 8 122 510 290 8 800 3.05kg 2.77kg
Outer Box 20 247 510 310 20 2000 7.55kg 6.85kg
Outer Box 40 320 510 360 40 4000 15.10kg 13.70kg
OUTER RSC
INNER BOXES (8PCS)
OUTER RSC
INNER BOXES (20PCS)
OUTER RSC
INNER BOXES (40PCS)
(L) 510mm X (W) 290mm X (H) 122mm (L) 510mm X (W) 310mm X (H) 247mm (L) 510mm X (W) 360mm X (H) 320mm
Figure 13. Dimensions for outer box packaging for LUXEON CoB (Gen2).
Figure 14. Example of outer box label for LUXEON CoB Core Range (Gen2).
DS155 LUXEON CoB Core Range (Gen 2)
Product Datasheet 20161105
©2016 Lumileds Holding B.V. All rights reserved.
LUXEON is a registered trademark of the Lumileds Holding B.V.
in the United States and other countries.
lumileds.com
Neither Lumileds Holding B.V. nor its aliates shall be liable for any kind of loss of data or
any other damages, direct, indirect or consequential, resulting from the use of the provided
information and data. Although Lumileds Holding B.V. and/or its aliates have attempted to
provide the most accurate information and data, the materials and services information and data
are provided “as is,” and neither Lumileds Holding B.V. nor its aliates warrants or guarantees
the contents and correctness of the provided information and data. Lumileds Holding B.V. and its
aliates reserve the right to make changes without notice. You as user agree to this disclaimer
and user agreement with the download or use of the provided materials, information and data.
About Lumileds
Lumileds is the global leader in light engine technology. The company develops, manufactures and distributes groundbreaking
LEDs and automotive lighting products that shatter the status quo and help customers gain and maintain a competitive edge.
With a rich history of industry “rsts,” Lumileds is uniquely positioned to deliver lighting advancements well into the future by
maintaining an unwavering focus on quality, innovation and reliability.
To learn more about our portfolio of light engines, visit lumileds.com.
Mouser Electronics
Authorized Distributor
Click to View Pricing, Inventory, Delivery & Lifecycle Information:
Lumileds:
LHC1-5080-1202 LHC1-3070-1211 LHC1-3570-1203 LHC1-3070-1203 LHC1-2290-1202 LHC1-2280-1211 LHC1-
2280-1202 LHC1-2290-1211 LHC1-3570-1211 LHC1-2280-1203 LHC1-2290-1203 L2C2-30801208E1500 L2C2-
30801203E0900 L2C2-30801211E1900 L2C2-30801202E0600 L2C2-30801205E1300 L2C2-30801204E1300 L2C2-
30801202E0900 L2C2-40701202E0900 L2C2-30701203E0900 L2C2-57701204E1300 L2C2-40801203E0900 L2C2-
57701203E0900 L2C2-35701204E1300 L2C2-22801205E1300 L2C2-27901205E1300 L2C2-35701208E1500 L2C2-
35801204E1300 L2C2-22901204E1300 L2C2-50701205E1300 L2C2-40801204E1300 L2C2-35801202E0900 L2C2-
40901202E0900 L2C2-40801205E1300 L2C2-22801208E1500 L2C2-40701205E1300 L2C2-27901202E0900 L2C2-
57701202E0900 L2C2-22801204E1300 L2C2-27901204E1300 L2C2-22801211E1900 L2C2-35701203E0900 L2C2-
30901208E1500 L2C2-35801208E1500 L2C2-50701203E0900 L2C2-22901203E0900 L2C2-35801211E1900 L2C2-
27801202E0900 L2C2-40901208E1500 L2C2-27801204E1300 L2C2-50801208E1500 L2C2-50801211E1900 L2C2-
22901211E1900 L2C2-22901205E1300 L2C2-40801202E0900 L2C2-30701205E1300 L2C2-35701211E1900 L2C2-
27801208E1500 L2C2-50701211E1900 L2C2-27801203E0900 L2C2-22901208E1500 L2C2-40901211E1900 L2C2-
22801202E0900 L2C2-22901202E0900 L2C2-50701204E1300 L2C2-30901205E1300 L2C2-35701205E1300 L2C2-
40701211E1900 L2C2-57701211E1900 L2C2-27901211E1900 L2C2-30901211E1900 L2C2-30701202E0900 L2C2-
35801203E0900 L2C2-40701203E0900 L2C2-30701204E1300 L2C2-35801205E1300 L2C2-40901205E1300 L2C2-
35901203E0900 L2C2-40901204E1300 L2C2-27801205E1300 L2C2-57701208E1500 L2C2-30701211E1900 L2C2-
35701202E0900 L2C2-22801203E0900 L2C2-40701204E1300 L2C2-57701205E1300 L2C2-35901205E1300 L2C2-
27801211E1900 L2C2-35901202E0900 L2C2-27901203E0900 L2C2-50701202E0900 L2C2-50801203E0900 L2C2-
35901204E1300 L2C2-30701208E1500 L2C2-40801211E1900 L2C2-50801205E1300 L2C2-50701208E1500 L2C2-
40901203E0900 L2C2-40801208E1500 L2C2-35901211E1900
