z Tyco Electronics High Speed Backplane Connectors Table of Contents High Speed Card Edge Products High Speed Standard Edge Connector SEC-Z Connector ene eee 177-186 Lee eee 178-183 eee eee eee ene eee teens 184-186 177 Catalog 1773095 Revised 12-08 www.tycoelectronics.com Dimensions are in millimeters and inches unless otherwise specified. Values in brackets are U.S. equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA: 1-800-522-6752 Canada: 1-905-470-4425 Mexico: 01-800-733-8926 C. America: 52-55-1106-0803 South America: 55-11-2103-6000 Hong Kong: 852-2735-1628 Japan: 81-44-844-8013 UK: 44-8706-080-208 sjanpold afipy pie) paads yfiyq178 z Tyco Electronics High Speed Backplane Connectors Product Facts w 1:1 signal-to-ground ratio = Designed for signal transmissions with rise and fall times of 0.5 nanoseconds or greater w 40 signal/ground pairs per linear inch = Less than 10 picosecond skew m= Propagation delay is typically 75 picoseconds from motherboard to daughtercard at the top of the connector w 43 ohm impedance w Multiple simultaneous switching: 7% max. @ 0.5 ns; 5% max. @ 1.0 ns m High performance maintained when using up to 50% of the ground contacts for power w 50 to 130 dual positions (in increments of 10) and 73 dual position Performance Specifications Contact Current Rating Signal contact 1 ampere max. Ground contact 1.5 amperes max. Preground contact 1 ampere max. Termination Resistance 20 milliohms max. (initial) 40 milliohms max. (final) Dielectric Withstanding Voltage 500 volts AC min. Insulation Resistance 1000 megohms min. Mating Force 2.78 N (10 oz] max. per dual signal/ground contact pair using test blade Durability (Mating Cycles) Tested to 25 cycles with test blade Application Temperature +215C for 120 seconds max. Operating Temperature Range -05C to +85C High Speed Standard Edge Connector High Speed Standard Edge connectors are the answer for a low cost, one-piece approach to high speed signal transmissions or den- sity requirements. These Tyco Electronics connectors have an upper row of signal contacts on 1.27 [.050] centerline with a lower row of ground contacts within each circuit cavity. This achieves 0.64 [.025] center- line density in a 1.27 [.050] centerline connector with 40 signal/ground pairs per linear inch and a 1:1 signal- to-ground ratio. The stag- gered contact height also reduces the daughtercard mating force. Board retainers align the connector with the mother- board and retain it for soldering. The use of high temperature tolerant materi- als ensures that these connectors will withstand various wave and reflow soldering techniques. Tyco Electronics High Speed Standard Edge connectors are available in sizes of 50 to 130 dual positions (in increments of 10) and a 73 dual position, with solder lead lengths of 2.54 [.100] and 3.18 [.125]. Catalog 1773095 Revised 12-08 www.tycoelectronics.com Dimensions are in millimeters and inches unless otherwise specified. Values in brackets are U.S. equivalents. to change. Dimensions are shown for reference purposes only. Specifications subject USA: 1-800-522-6752 Canada: 1-905-470-4425 Mexico: 01-800-733-8926 CG. America: 52-55-1106-0803 South America: 55-11-2103-6000 Hong Kong: 852-2735-1628 Japan: 81-44-844-8013 UK: 44-8706-080-208! [ 3.43-4.19 So ew aL Tyco Electronics High Speed Backplane Connectors High Speed Standard Edge Connector (Continued) Accepts 4 favavaTalalalalalalatalalalalalalalalalalalatalal 1.37 -1.768 Oo00000008 [.054 .070] Layo] Max, p ats b [054-0701 | /-y iggooosocooosoooood Housing 15.49 - 15.62 [610-.615) YP A Max. Siqnal z=+-- . T ") ) 18.17 Max. (contacts Y= 7 e| | jx 2-769 2.819 [.715] 2 Ples. Ground \ | | i (109 ~ 111] | 5.70-7.70 Contact . rt - [.265 .305] ' 10.54 10.80 | [.415 .425] all 1 t | [.135 -.165] 4] Solder Shield 1.02 4.02 L120] 5.08 | a0 305 5:08 I F Spaces at 1-27 >| L< G Spaces at 12? > [200] +! [ 120] I 120] - [-200] P [.050] P [.050] f D E | Section Y-Y Section Z-Z 3.18 \, . [125] Virtual Size | 0.81 1.032] Virtual Size Dimensions No. of Dual Part A B Cc D E F G H J Positions Number 155.35 66.42-66.68 83.95-84.20 66.73-66.88 84,.25-84.40 47 61 4.44-4,95 2.29-2.79 410 5145236-1 6.116 2.615-2.625 3.305-3.315 2.627-2.633 3.317-3.323 .175-.195 .090-.110 108.36 46.10-46.36 57.28-57.53 46.41-46.56 57.58-57.73 34 40 4,44-4,95 2.29-2.79 73 5145236-2 4.266 1.815-1.825 2.255-2.265 1.827-1.833 2.267-2.273 .175-.195 .090-.110 155.35 66.42-66.68 83.95-84.20 66.73-66.88 $4,25-84.40 4.44-4.95 2.92-3.43 6.116 -2.615-2.625 3.305-3.315 2627-2633 3.317-3.323 a7 61 175-195 115-135 110 5145236-3 Note: All part numbers are ROHS compliant. 179 Catalog 1773095 Revised 12-08 www.tycoelectronics.com Dimensions are in millimeters and inches unless otherwise specified. Values in brackets are U.S. equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA: 1-800-522-6752 Canada: 1-905-470-4425 Mexico: 01-800-733-8926 C. America: 52-55-1106-0803 South America: 55-11-2103-6000 Hong Kong: 852-2735-1628 Japan: 81-44-844-8013 UK: 44-8706-080-208 sjanpold afipy pie) paads yfiyq180 Tyco Electronics High Speed Backplane Connectors High Speed Standard Edge Connector (Continued) Accepts SAU A PA PAP eee ee Pray AA . 1.37 =1.78 11,94 SN BOOERRESIDOO0COO0LE goo 1 [054 - .070] L470] ax. I w crororor aaa rare ares rar Daughtercard . HOHOGGEH 2c 0000000006 gaa } { A WWW Fo JOD? Housing 15,49 15.62 [610-615] "YP A Max. | c Signal | Contacts 2.769 2.819 18.17 Max. 1 S409 444 [.715] 2 Ples. Ground - [ MY 6.70-7.70 Contact ac t [.265 - .305] i x | ' #, 10.54-10.80 % vy [.415- 425] 7 | 3.43 - 4. [.135 .165] Metal +? Y uv _ le 3.05 H Hold-Down 040] (040) = 130) | . , . [180] [.120] 3 Ples. 5.08 3.05 3.05 5.08 F Spaces at 1-27 G Spaces at 127 [200] "= aeo) Lior [.200] [050] [.050] f D E | Section Y-Y Section Z-Z 3.18 hmannann (125) Virtual Size Ce A 632) Virtual Size Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 Revised 12-08 and inches unless otherwise reference purposes only. Canada: 1-905-470-4425 Hong Kong: 852-2735-1628 specified. Values in brackets Specifications subject Mexico: 01-800-733-8926 Japan: 81-44-844-8013 www.tycoelectronics.com are U.S. equivalents. to change. C. America: 52-55-1106-0803 UK: 44-8706-080-208Tyco Electronics High Speed Backplane Connectors High Speed Standard Edge Connector (Continued) Dimensions No. of Dual Part A B c D E F G H J Positions Number 2.29-2.79 79.15 33.40-33.66 40.77-41.02 33.71-33.66 -41.07-41.22 4 37 4.44-4.95 __.090-.110 0 9145090"1 3.116 1.315-1.325 1.605-1.615 = 1.327-1.333 1.617-1.623 175-195 ~ 2.92-3.43 a15. 135 50 5145090-2 ato 80 5145090-5 91.85 38.48-38.74 48,39-48.64 -38.79-38.94 46,69-48.84 4.44-4.95 2.92-3.43 3.616 1515-1525 1905-1915 1.527-1.533 1.917-1.923 28 38 175-195 115-135 60 51450906 43t 08 80 5145090-8 2.29-2.79 70 5145090-9 104.55 43.56-43.82 55.01-56.26 43.87-44.02 56.31-56.46 29 39 4.44-4.95 __ -090-.110 4.416 9 1,.715-1.725 2.205-2.215 = 1.727-1.733 2.217-2.223 175-.195 ; 792350 70 1-5145090-0 2.29-2.79 80 1-5145090-3 117.25 1.18-51.44 6 1.09-61.34 51.49-51.64 6 1.39-61.54 35 43 4.44-4.95 __.090-.110 4.616 2.015-2.025 2.405-2.415 2.027-2.033 2.417-2.423 175-195 ~ 3.92-3.43 115.135 80 1-5145090-4 ao ite 90 1-5145090-7 129.95 56.26-56.52 68.71-68.96 56.57-56.72 69.01-69.16 4.44-4.95 2.92-3.43 5.116 = 2.215-2.225 2.705-2.715 2.027-2.233 -2.717-2.723 so 49 175-195 115-135 90: 15145090-8 see 90 1-5145090-9 2.29-2.79 142.65 61.34-61.60 76.33-76.58 61.65-61.80 76.63-76.78 43 55 4.44-4.95 __.090-.110 109 810001 5.616 2.415-2.425 3,005-3.015 = 2.427-2.493 3.017-3.023 175-195 ~ 2.92.3.43 415-135 100 -2-5145090-2 ae ane 110 -2-5145090-5 2.92-3.43 110 2-5145090-6 155.35 66.42-66.68 83.95-84.20 66.73-66.88 84.25-84.40 a7 61 4.44-4.95 _ .115-.135 6.116 -2.615-2.625 = 3.305-3.315 2.627-2.633 3.317-3.323 175-195 3.68-4.19 145.165 110 2-5145090-7 ae oon 110 2-5145090-8 ato 120 2-5145090-8 168.05 = 71.50-71.76 91.57-91.82_71.81-71.96 91.87-92.02 4.44-4.95 2.92-3.43 6.616 2,815-2.825 3.605-3.615 2.827-2.833 3.617-3.623 $1 67 175-195 115-135 120 $5145090-0 36e48 120 3-5145090-1 220-279 130 3-5145090-3 180.75 79.12-79.38 96.65-96.90 79.43-79.58 96.95-97.10 4.44-4.95 2.92-3.43 7416 3.115-3.125 3.805-3.815 3.127-3.133 3.617-3823 O77 175-495 415-135 130 $9145090-4 Se ae 130 3-5145090-5 2.29-2.79 . 73 3-5145090-7 108.36 46.10-46.36 57.28-57.53 46.41-46.56 _57.58-57.73 31 40 4.44-4,95 _ .090-.110 4.266 = 1,815-1.825 2.255-2.265 = 1.827-1.833 2.267-2.273 175-195 ~3.92.3.43 : 415-135 73 3-5145090-8 *Alternate Pattern Applies. Note: All part numbers are ROHS compliant. 181 Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 Revised 12-08 and inches unless otherwise reference purposes only. Canada: 1-905-470-4425 Hong Kong: 852-2735-1628 specified. Values in brackets Specifications subject Mexico: 01-800-733-8926 Japan: 81-44-844-8013 www.tycoelectronics.com are U.S. equivalents. to change. C. America: 52-55-1106-0803 UK: 44-8706-080-208 sjanpold afipy pie) paads yfiyqz Tyco Electronics High Speed Backplane Connectors High Speed Standard Edge Connector (Continued) Accepts t | 1.37 - 1.78 [.054 .070] 11.94 [.470] Daughtercard yh Housing * A Max - B | Cc | Signal 2.769 2.819 15.49 15.62 , | [.109 .111] L610-.615] 7 Contacts 0.25 - 0.51 Ground ' [.010 .020] 6.70 7.70 Contact ty . [.265-.305]) gree y 7 BA elt y 10.54 10.80 J Ip il [415 ~ 425] _ Al eB I 3.43 4.19 2 i one | [.135 - .165] 4] rs | Solder Shield H Metal Hold-Down bose] rag] 120 3 Plies, 5.08 |. tl sos 3.05 5.08 1.27 [120] 1.27 [.200] +3: 05 | [.200] < F Spaces at 050) |< G Spaces aty 050) [120] [120] D E Section Y-Y Section Z-Z 3.18 Virtual Size 135) Virtual Size dk [125] t == 082 Virtual Size Dimensions No. of Dual Part A B c D E F G H J Positions Number 108.36 46.10-46.36 57.28-57.53 46.41-46.56 57.58-57.73 4.44.4,95 2.29-2.79 4.266 1,815-1,825 2.255-2,965 1,827-1.833 _2,267-2,273 2 40 175-195 ,090-.110 7 S14b4e 1 Note: All part numbers are ROHS compliant. 182 Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 Revised 12-08 and inches unless otherwise reference purposes only. Canada: 1-905-470-4425 Hong Kong: 852-2735-1628 specified. Values in brackets Specifications subject Mexico: 01-800-733-8926 Japan: 81-44-844-8013 to change. C. America: 52-55-1106-0803 UK: 44-8706-080-208 www.tycoelectronics.com are U.S. equivalents.z Tyco Electronics High Speed Backplane Connectors Part Number 5145094-6 30 Dual Positions High Speed Standard Edge Connector (Continued) Accepts WAN ARS 1.37 - 1.78 met | [.054 -.070) ae Daughtercard a6 LN ii Housing 6.45 12.616] 15.49 - 15.62 J,_ sCi2GB-2B7Z TG BRAN [.610 - .615] YP [1.129 - 1.131] [1.305 - 1.915] 26.32-28.58 18.17 Max. ZL [1.415-1125) | __ 2-769 2.819 [715] 2 Ples. Y= [109 111] mee 6.70 -7.70 t [.265 .305] re | 2.92-3.43 [fH 7 Hat [.415.135) (UM Typ. UNO UN "% 17 Spaces at L eI 3.1 [125] 8 Virtual Size 032] Virtua NRG GeL 62.15 62.31 [2.447 2.453] IRE Hk ee, 5 | Size 21 Spaces at 1.27 [.050) Note: All part numbers are ROHS compliant. 3.43-4.19 = Signal * Contacts Ground Co matt g + [.135 .165] ( Metal 1.02 1.02 Hold-Down [.040] [.040] a 4.44 - 4.95 00) ~ | 3.05 0) [.175 .195] oa [.120] 5.08 -| 2 Ples. [120] [.200] Section Y-Y Section Z-Z 3.18, , 125] Virtual Size { | 183 Catalog 1773095 Revised 12-08 www.tycoelectronics.com Dimensions are in millimeters and inches unless otherwise specified. Values in brackets are U.S. equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA: 1-800-522-6752 Canada: 1-905-470-4425 Mexico: 01-800-733-8926 C. America: 52-55-1106-0803 South America: 55-11-2103-6000 Hong Kong: 852-2735-1628 Japan: 81-44-844-8013 UK: 44-8706-080-208 sjanpold afipy pie) paads yfiyq184 Tyco Electronics High Speed Backplane Connectors SEC-Z Connector Product Facts w High density card edge connector for high speed signal applications mw Used in servers, workstations, high-end PCs a Memory Expansion connector = High performance and multiple CPU interface (SPARC, Alpha, AMD) m 0.64 [.025] centerline density with 1.27 [.050) centerline daughtercard allawances m High density: 80 lines/inch m 100 cycles, min. durability w Available in sizes fram 240 position to 520 position (40 position increments) Active Part Numbers (additional sizes may be available) 1.57 [.062] thick daughtercard 240 position 145427-5 280 position 145427-5 360 position 1-5145427-7 440 position 6658664-2 520 position 3-5145427-3 2.36 [.093] thick daughtercard 480 position 2-5145400-9 Product Specification 108-1863 Electrical Characteristics Crosstalk Less than 1% @ 200 pS, 1:1 signal/ground ratio Current Rating 1 ampere/contact ALPHA is a trademark of Digital Equipment Corporation. AMD is a trademark of Advanced Micro Devices, Inc. SPARC is a trademark of SPARC International, Inc. Note: All part numbers are RoHS compliant. Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 Revised 12-08 and inches unless otherwise reference purposes only. Canada: 1-905-470-4425 Hong Kong: 852-2735-1628 specified. Values in brackets Specifications subject Mexico: 01-800-733-8926 Japan: 81-44-844-8013 www.tycoelectronics.com are U.S. equivalents. to change. C. America: 52-55-1106-0803 UK: 44-8706-080-208z Tyco Electronics High Speed Backplane Connectors SEC-Z Connector (Continued) 1.78 070)" 9 6g Ret AANA AMAR 106) 2" 0.43 oooo Qoooo ate Lot] Ref. Lot] Ret Janaad f||_ananap + 0.48 0.53 Heaoe NY RHEE i | | corn Max | abe mex UA A 2.36 ccepts [.093] 4| (023 ~ |. 017 2 Housing Daughtercard (009) Ref. (.0o7] " Section D-D Section C-C 15.49 15.62 - A Maw. [610-615] YP Yoner Row I B c | Contacts yt 1 2.769 - 2.819 ia wa Lower Row 1 [.109 -.111] , . Contacts D, a 6.70 -7.70 L r [.265 - .305] f | | | i y 10.54 - 10.80 1 r | fl [415 .425] J qj 14 { Typ. 318-304 Upp ' [125 155] r r Metal ~- 1.02 1.02 _ 3.30 3.81 " : Y~= - H Fastener 2.29 | [7 4 04 2.29 = [130] |. aI 1.150) Pe". 3 Ples, [.090] i as aes I [.090] 1.27 1.27 5.72 483 |= Ky i401 4.83 F Spaces at [.050) G Spaces at 050] TT [205] ef. [190] [140] [.140] L190] f D E 1.91 poy Section Y-Y Section Z-Z [.075] " 00.03 |. a Virtual Condition 3.18 |. . [.001] Virtual Size 3.18 |, . [.125] [125] Virtual Size i i fi nit int] 1 i i > ACU CEG bal ad fal } Pe ty hg gt eh gt yt t al i | ang tenn amt (ee nt Hh OOO _,||._ 0.81 [032] Virtual Size Dimensions No. of Total No.of Quad Part A B c D E F G H J Positions Positions Number 168.05 71.50-71.76 91.57-91.82 71.81-71.96 91.87-92.02 4.44-4,95 2.29-2.79 6.616 2.8152.825 3.605-3.615 2827-2833 3617-3623 ' 87 475.495 (090-.110 480 120 6-5145400-1 47.40 18.16-18.41 24.26-24.51 18.47-18.62 24.56-24.71 4.44-4,95 2.29-2.79 1.866 715.725 955-965 727-733 967-973 9 = 14 475-195 .090-.110 100 25 -2-5145400-9 Note: All part numbers are ROHS compliant. Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 reference purposes only. Specifications subject to change. and inches unless otherwise specified. Values in brackets are U.S. equivalents. Revised 12-08 www.tycoelectronics.com Canada: 1-905-470-4425 Mexico: 01-800-733-8926 C. America: 52-55-1106-0803 Hong Kong: 852-2735-1628 Japan: 81-44-844-8013 UK: 44-8706-080-208 185 sjanpold afipy pie) paads yfiyqTyco Electronics High Speed Backplane Connectors SEC-Z Connector (Continued) 1.73 [.070] Min. Accepts i ANNAN AMA 1.37 - 1.78 pogo ooo [.054 .070] 11.94 A i Daughtercard ate 000 Goon 4 +1 DOWD yyy uo 1.78 Housing 079] M'"- 15.49 - 15. 62 5, A Max. Lsto.615] | Signal Cc | 18.47 M Contacts. AX, 2.769 2.819 Ground [.109 .111] [715] 2 Ples. Contacts | oI 6.70 - 7.70 | 1 (265 .305] f 10.54 - 10.80 [.415 - 425] | { li aL 3.43 - 4.19 [.135 165] if r {ft Metal _ - 0.64 w| be 3.81 H__ Fastener 4.91 <7 /.025 025] |e. 1-91 7 [1201 (150) 9" 3 Ples. [.075] 3.18 3.18 ! [075] QF . 27 5.72 4.45 a - = 4.45 F Spaces at oso) i G Spaces at 680) K 225) Ref. [175] [125] [.125] 175) D E 1.91 pos Section Y-Y Section Z-Z 1.075] Pet 00.03 3.18 Virtual Condition 001 L 125) ViTtual Size [ } 3.18 Virtual Size =| [032] Virtual Size Dimensions No. of Total No.of Quad Part A B Cc D E F G H J Positions Positions Number 91.85 38.48-38.74 48.39-48.64 38.79-38.94 48.69-48.84 4.44-4.95 2.29-2.79 3.616 1.515-1.525 1.905-1.915 1527-1583 1917-1923 33 475.1495 o90-.110 240 60 5145427-5 104.55 43.56-43.82 56.01-56.26 43.87-44.02 56.31-56.46 4.44-4.95 2.29-2.79 4.116 9 1.715+1.725 2.205-2.215 1.727-1.733 2217-22293 9 39 475.495 090-110 280 70 5145427-9 129.95 56.26-56.52 68.71-68.96 56.57-56.72 69.01-69.16 4.44-4.95 2.29-2.79 5.116 2.152.995 2.705-2.715 2.927-2.933 2717-2723 39 49 475.1495 090-110 360 90 1-b145427-7 155.35 66.42-66.68 63.95-84.20 66.73-66.68 64.25-B4.40 444-495 2.29-2.79 : 6.116 2.615-2.625 3305-3315 26272633 33173923 7 81 475.495 o90-.110 440 110 8658664-2 180.75 = =79.12-79.38 96.65-96.90 79.43-79.58 96.95-97.10 4.44-4.95 = 2.29-2.79 7.4116 3.115-3.125 3.805-3.815 3.127-3.133 3817-3823 97 71 475.7495 090-110 520 130 3-5145427-3 206.15 89.28-89.54 111.89-112.14 89.59-89.74 112.19-112.34 4.44-4.95 2.29-2.79 8.116 3.153.525 4.405-4.415 3527-3533 4417-4493 8 838 476495 o90-.110 600 150 4-5145427-1 237.90 103.25-103.51 129.67-129.92 103.56-103.71 129.97-130.12 7, 97 4.44-4.95 _2.29-2.79 700 475 6-5145497.3 9.366 4.065-4.075 5.105-5.115 4.077-4.083 5.12-5.12 .175-.195 .090-.110 Contact Area Lubricated with Bellcore Approved Lubricant. Technical Reference GR-1217-Core. Issue 1, November 1995. Note: All part numbers are ROHS compliant. 186 Catalog 1773095 Dimensions are in millimeters Dimensions are shown for USA: 1-800-522-6752 South America: 55-11-2103-6000 Revised 12-08 and inches unless otherwise reference purposes only. Canada: 1-905-470-4425 Hong Kong: 852-2735-1628 specified. Values in brackets Specifications subject Mexico: 01-800-733-8926 Japan: 81-44-844-8013 www.tycoelectronics.com are U.S. equivalents. to change. C. America: 52-55-1106-0803 UK: 44-8706-080-208