3MTM Twisted Pair Flat Cable .050" 28 AWG Stranded, Mass Terminatable, PVC 3782 Series * Combines the advantages of loose twisted pairs with flat section parts for mass termination * Loose twisted pairs allow for easy routing * Twisted pairs reduce crosstalk for balanced drive applications * Zippable for branching or discrete termination * Wires are color-coded for easy identification * See Regulatory Information Appendix (RIA) for chemical compliance information Date Modified: May 14, 2009 TS-0999-D Sheet 1 of 2 Physical Insulation Material: Polyvinyl Chloride (PVC) Color: 10 Color Repeat with White Common Marking: Standard: None Conductors: 28 AWG, 7 x 36 AWG [ 7 x o 0.127 ] Tinned Stranded Copper Electrical EU: <50V Voltage Rating: USA: 300V Insulation Resistance: > 1 x 1010 /10 ft. [ 3 m ] Unbalanced Characteristic Impedance: Unbalanced Capacitance: Inductance: Propagation Delay: Velocity of Propagation: 103 137 14.8 pF/ft [ 48.5 pF/m ] 11.1 pF/ft [ 36.3 pF/m ] 0.16 H/ft [ 0.52 H/m ] 0.21 H/ft [ 0.69 H/m ] 1.52 ns/ft [ 4.99 ns/m ] 1.52 ns/ft [ 4.99 ns/m ] 67% 67% Note: Unbalanced is measured between ground-signal-ground conductors. Balanced is measured between signal conductors within a pair. Environmental Temperature Rating: USA: -20 C to +80 C Flammability Rating: USA:VW-1 3 Electronic Solutions Division Interconnect Solutions http://www.3M.com/interconnects/ 3M is a trademark of 3M Company. For technical, sales or ordering information call 800-225-5373 3MTM Twisted Pair Flat Cable .050" 28 AWG Stranded, Mass Terminatable, PVC 3782 Series Number of Pairs 3M Part Number Dimension A Dimension B 5 3782-5P-XXXA 100FT 0.50 [12.70] 0.450 .010 [ 11.43 ] 7 3782-7P-XXXA 100FT 0.70 [17.80] 0.650 .010 [ 16.51 ] 8 3782-8P-XXXA 100FT 0.80 [20.30] 0.750 .010 [ 19.50 ] 10 3782-10P-XXXA 100FT 1.00 [25.40] 0.950 .020 [ 24.13 ] 12 3782-12P-XXXA 100FT 1.20 [30.50] 1.150 .020 [ 29.21 ] 13 3782-13P-XXXA 100FT 1.30 [33.00] 1.250 .020 [ 31.75 ] 15 3782-15P-XXXA 100FT 1.50 [38.10] 1.450 .020 [ 36.83 ] 17 3782-17P-XXXA 100FT 1.70 [43.20] 1.650 .020 [ 41.91 ] 20 3782-20P-XXXA 100FT 2.00 [50.80] 1.950 .020 [ 49.53 ] 25 3782-25P-XXXA 100FT 2.50 [63.50] 2.450 .020 [ 62.23 ] 30 3782-30P-XXXA 100FT 3.00 [76.20] 2.950 .020 [ 74.93 ] 32 3782-32P-XXXA 100FT 3.20 [81.30] 3.150 .020 [ 80.01 ] 34 3782-34P-XXXA 100FT 3.40 [86.40] 3.350 .020 [ 85.09 ] * 10 Color Repeat Brown/White Red/White Orange/White Yellow/White Green/White Blue/White Violet/White Gray/White Pink/White Black/White * White * Brown (See note 1) Clear PVC Carrier Flat Area Only 28 AWG, 7 X 36 AWG ( 7 X o 0.127) Tinned Stranded Copper Conductors .050 .006 Typ [ 1.27 mm ] .035 Nominal [ .09 ] Flat area only Section thru Flat B A Inch [mm] 2.0 0.3 [ 51 ] Tolerance Unless Noted repeat (see ordering information) Inch Note: 1. Brown conductor indicates conductor number 1. 2. RIA E1 & C1 apply for all cables listed .0 .00 .000 .1 .01 .005 [ ] Dimensions for Reference Only Ordering Information 3782/XXP XXXA 270 = 270 mm repeat 540 = 540 mm repeat Note: Available in standard 100 ft rolls. Contact 3M for availability of additional conductor counts and/or custom roll lengths. 3 Electronic Solutions Division Interconnect Solutions http://www.3M.com/interconnects/ Number of Pairs (See Table) TS-0999-D Sheet 2 of 2 3M is a trademark of 3M Company. For technical, sales or ordering information call 800-225-5373 Regulatory Information Appendix 3M Electronic Solutions Division/Interconnect EUROPE Appendix E1: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product is RoHS Compliant 2005/95/EC. "RoHS Compliant 2005/95/EC" means that the product or part ("Product") does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. Appendix E2: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product contains lead in the compliant pin area in excess of the maximum concentration value allowed but is compliant by exemption under EU Commission Decision 2005/747/EC. "RoHS Compliant 2005/95/EC" means that the product or part ("Product") does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. Appendix E3: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment as amended by Commission Decision 2005/618/EC. This product contains lead in the solder tail area in excess of the maximum concentration value allowed. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. Appendix E4: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC, as amended by EU Commission Decision 2005/717/EC, as amended by EU Court of Justice Decision 2008/C 116/04 This product contains decaBDE in the insulating material in excess of the maximum concentration allowed for finished products subject to EU RoHS that are placed on the EU market after June 30, 2008. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. RIA-2217B-E Appendix E5: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product contains lead in excess of the maximum concentration value allowed but is compliant by exemption under Item 6 of the Annex to the Directive. "RoHS Compliant 2005/95/EC" means that the product or part ("Product") does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. CHINA Appendix C1: China RoHS Electronic Industry Standard of the People's Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does not contain any of the following substances in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the Warranty stated below. Appendix C2: China RoHS Electronic Industry Standard of the People's Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. The numerical reference in the symbol above should not be construed as a representation regarding the product's life or an extension of a product warranty. The product warranty is stated below. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the product Warranty stated below. RIA-2217B-E Appendix C3: China RoHS Electronic Industry Standard of the People's Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M's best knowledge and belief based upon information provided by third party suppliers to 3M. The numerical reference in the symbol above should not be construed as a representation regarding the product's life or an extension of a product warranty. The product warranty is stated below. In the event any product is proven not to conform with 3M's Regulatory Information Appendix, then 3M's entire liability and Buyer's exclusive remedy will be in accordance with the product Warranty stated below. Important Notice All statements, technical information, and recommendations related to 3M's products are based on information believed to be reliable, but the accuracy or completeness is not guaranteed. Before using this product, you must evaluate it and determine if it is suitable for your intended application. You assume all risks and liability associated with such use. Any statements related to the product which are not contained in 3M's current publications, or any contrary statements contained on your purchase order shall have no force or effect unless expressly agreed upon, in writing, by an authorized officer of 3M. Warranty; Limited Remedy; Limited Liability. This product will be free from defects in material and manufacture for a period of one (1) year from the time of purchase. 3M MAKES NO OTHER WARRANTIES INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. If this product is defective within the warranty period stated above, your exclusive remedy shall be, at 3M's option, to replace or repair the 3M product or refund the purchase price of the 3M product. Except where prohibited by law, 3M will not be liable for any indirect, special, incidental or consequential loss or damage arising from this 3M product, regardless of the legal theory asserted. 3 3M Electronics Solutions Division 6801 River Place Blvd. Austin, TX 78726-9000 U.S.A. 1-800-225-5373 www.3m.com/interconnects Please recycle. Printed in USA. (c) 3M 2008. All rights reserved. RIA-2217B-E 3M is a trademark of 3M Company.