HPS3000-9 - EMERSON�NETWORK POWER

Rev. 02.22.11_81

HPS3000 Series

1 of 8

Embedded Power for

Business-Critical Continuity

HPS3000 Series

3000 Watts

Special Features

•3000Woutputpower

•40W/cu-in

•Optionalcustomerprovidedair

•1Ux3Uformfactor

•N+1Redundant

•Hot-swap

•InternalOR-ing

•5Vhousekeeping

•Highefciency89%@200Vac,

100%load

•Variablespeed“smartfans”

•Twoyearwarranty

Distributed Power Bulk Front-End

Single Output

ElectricalSpecications

Safety

Input

Inputrange(operating): 180-264Vac

90-140Vac

Inputrange(nominal): 200Vac

110Vac

InputthroughCardEdgeConnection

on same end as DC output

Frequency: 47to63Hz

Inputfusing: Internal25Afuses Bothlinesfused

Inrushcurrent: ≤40Apeak Eitherhotorcoldstart

Powerfactor: 0.97typical MeetsEN61000-3-2

Harmonics: MeetsIEC1000-3-2

requirements

@50%load

Inputcurrent: 19Amaxinputcurrent

Holduptime: 10msminimum Atfullratedload

Leakagecurrent: 1.4mA At240Vac

Powerlinetransient: MOVdirectlyafterthefuse

• UL/cUL 60950

• CSA  60950

• China CCC

• Nemko TUV

• CB Report

• CSA 22.2 60950

Compliance

•POEIsolation

•EMIClassB-EN55022,Level“A”

 @230Vac

•EN61000Immunity

Rev. 02.22.11_81

HPS3000 Series

2 of 8

Embedded Power for

Business-Critical Continuity

Output

Outputrating 48V@62.0A

5Vsb@3.0A

180-264Vac

48V@29.4A

5V@3A

90-140Vac

Set point 48V Programmable96-117%throughI2C serial bus

Totalregulationrange 48V±5%

5Vsb±4%

Line/load/transientwhenmeasuredatoutputconnection

Ratedload 3000Wmaximum@200VacInput

1500Wmaximum@110VacInput

Noderatingoveroperatingtemprange

Minimum load 48V@0.0A

5Vsb@0.0A

Nolossofregulation

Outputnoise 480mVmaxP-P

100mVmaxP-P

48Voutput

5Vsboutput

Measuredwitha0.1µFCeramicand10µFTantalumcapacitoronany

input

Outputvoltageovershoot ±5%maximum NominalVoltageSetting

Transientresponse 5%maximumdeviation 50%loadstep@1A/us

Steploadvalidbetween10%to100%ofoutputrating.

Maxunitsinparallel Upto4 Totalpowerin1U19”rackis12KW

Shortcircuitprotection 120%-130%ofratedoutput Outputtoreturn

Outputisolation PerPOEspecs >2000Vac

Forcedloadsharing Within10%ofallsharedoutputs Digitalsharingcontrol

Overcurrentprotection(OCP) 120%to130%

110%to140%

48Voutput

5Vsboutput

Overvoltageprotection(OVP) 110%to133%

110%to125%

48Voutput

5Vsboutput

Overtemperatureprotection 10-15degCabovesafe

operatingarea

BothPFCandoutputconvertermonitored

5Vsbwilloperateunderovertemperaturecondition.

Builtinhysteresis

230Vac Efficiency

10.00

20.00

30.00

40.00

50.00

60.00

70.00

80.00

90.00

100.00

10 20 30 40 50 60 70 80 90 100

% of Total Output Power

230VacEfciency

EnvironmentalSpecications

Vibration/Shock: Non-operational5GSinesweepfrom5Hzto500Hz,dwellingatresonantfrequenciesfor1houreach

Operatingtemperature: -10°to+40°C

StorageTemperature: -40°to+85°C

Cooling ExternalfanswithFanFailandFanSpeedcontrol

OperatingRelativeHumidity: 5%to95%non-condensing

StorageRelativeHumidity: 5%to95%non-condensing

OperatingAltitude Upto10,000feetabovesealevel

StorageAltitude: Upto30,000feetabovesealevel

RoHSCompliant: Yes

Embedded Power for

Business-Critical Continuity

Embedded Power for

Business-Critical Continuity

Rev. 02.22.11_81

HPS3000 Series

3 of 8

(Allunitsinmm)

ModuleInformation

Embedded Power for

Business-Critical Continuity

Embedded Power for

Business-Critical Continuity

PinAssignments

Bottom Top

Rev. 02.22.11_81

HPS3000 Series

4 of 8

64 ACLINE

63 ACLINE

62 n.c.

61 ACNEUTRAL

60 ACNEUTRAL

59 n.c.

58 n.c.

57 n.c.

56 +48Vdcout

55 +48Vdcout

54 +48Vdcout

53 +48Vdcout

52 +48Vdcout

51 +48Vdcout

50 +48Vdcout

49 +48VdcRTN

48 +48VdcRTN

47 +48VdcRTN

46 +48VdcRTN

45 +48VdcRTN

44 +48VdcRTN

43 +48VdcRTN

42 n.c.

41 SYS_GND

40 Reserved

39 ACOK#

38 SMBUS_ALERT_OUT

37 SCL

36 A2

35 PSKILL

34 A1

33 A0

1ACLINE

2 ACLINE

3n.c.

4ACNEUTRAL

5 ACNEUTRAL

6n.c.

7n.c.

8n.c.

9+48Vdcout

10 +48Vdcout

11 +48Vdcout

12 +48Vdcout

13 +48Vdcout

14 +48Vdcout

15 +48Vdcout

16 +48VdcRTN

17 +48VdcRTN

18 +48VdcRTN

19 +48VdcRTN

20 +48VdcRTN

21 +48VdcRTN

22 +48VdcRTN

23 n.c.

24 V_STBY

25 Reserved

26 PRESENT#

27 DCOK/PWOK#

28 SDA

29 HVCC

30 PSON#

31 #ALERT

32 ISHARE

Embedded Power for

Business-Critical Continuity

TPWOK_Off_

AC Input

Main Vout

Timing Diagram

TAC_On_Delay

TVout_Holdup

TPWOK_On

AC Input

ON / OFF Cycle

AC_OK

PS_ON

3.3 V Vout

PWOK

PSON

ON / OFF

Cycle

Tsb_On

TSB_Vout

TPWOK_Delay

TPWOK_Off_

PWOK_Off_

TPWOK_On

TPWOK_Off_

TPWOK_On

TACOK_Delay

TPSON_On_Delay

TPSON_PWOK

TPWOK_Off

AC On

Rev. 02.22.11_81

HPS3000 Series

5 of 8

Rev. 02.22.11_81

HPS3000 Series

6 of 8

Embedded Power for

Business-Critical Continuity

TimingSignalDenitions

TurnON/OFFTiming

Item Description Min Max Units

Tvout_rise 48VOutputrisetime 5 300 msec

Tsb_on_delay DelayfromACbeingappliedto5Vsbbeingwithinregulation. 1500 msec

Tac_on_delay DelayfromACbeingappliedtoalloutputvoltagesbeingwithin

regulation.

2000 msec

Tvout_holdup Timealloutputvoltages,including5Vsb,staywithinregulation

afterlossofAC.

10 msec

Tpwok_holdup DelayfromlossofACtode-assertionofPWOK 5 msec

Tpson_on_delay DelayfromPSON#activetooutputvoltageswithinregulation

limits.

5 400 msec

Tpson_pwok DelayfromPSON#de-activetoPWOKbeingde-asserted. 50 msec

Tacok_delay DelayfromlossofACinputtode-assertionofACOK#. 10 msec

Tpwok_on DelayfromoutputvoltageswithinregulationlimitstoPWOK

asserted at turn on.

100 1000 msec

Tpwok_off DelayfromPWOKde-assertedto48Vdroppingoutofregulation

limits.

1 1000 msec

Tpwok_low DurationofPWOKbeinginthede-assertedstateduringanoff/on

cycleusingACorthePSON#signal.

100 msec

Tsb_vout Delayfrom5Vsbbeinginregulationto48Vbeingin

regulationatACturnon.

50 2000 msec

PSON#

ThePSON#signalisrequiredtoremotelyturnon/offthepowersupply.PSON#isanactivelowsignal

thatturnsonthe48Vpowerrail.Whenthissignalisnotpulledlowbythesystem,orleftopen,the

48Voutputturnsoff.The5Vsboutputremainson.Thissignalispulledtoastandbyvoltagebya

pull-upresistorinternaltothepowersupply.Thepowersupplyfan(s)shalloperateatthelowestspeed.

PSON#SignalCharacteristic

SignalType Acceptsanopencollector/draininputfrom

thesystem.Pulled-uptothe5Vsblocatedin

power supply.

PSON#=Low ON

PSON#=Open OFF

MIN MAX

Logiclevellow(powersupplyON) 0V 0.4V

Logiclevelhigh(powersupplyOFF) 2.40V 3.40V

Sourcecurrent,Vpson=low -- 4mA

Powerupdelay:Tpson_on_delay 5msec 400msec

SignalsandControls-AllModels

Rev. 02.22.11_81

HPS3000 Series

7 of 8

Embedded Power for

Business-Critical Continuity

 PWOK#(PowerGood)

PWOK#isapowergoodsignalandwillbepulledLOWbythepowersupplytoindicatethatboththe

outputsareabovetheregulationlimitsofthepowersupply.Whenanyoutputvoltagefallsbelow

regulationlimitsorwhenACpowerhasbeenremovedforatimesufcientlylongsothatpowersupply

operationisnolongerguaranteed,PWOKwillbede-assertedtoaHIGHstate.ThestartofthePWOK#

delaytimeshallbeinhibitedaslongasthe48Voutputisincurrentlimitorthe5Vsboutputisbelow

theregulationlimit.

 PowerSupplyPresentIndicator(PRESENT#)

ThePRESENT#signalisprimarilyusedtoprovideamechanismbywhichthehostsystemcansensethe

numberofpowersuppliesphysicallypresent(operationalornot).Thispinisconnectedtogroundinthe

power supply.

 ACINPUTPresentIndicator(ACOK#)

TheACOK#signalisusedtoindicatepresenceofACinputtothepowersupply.Thissignalshallbe

connectedto5Vsbthrougharesistoronthehostsystemside.Alogic“Low”levelonthissignalshall

indicateACinputtothepowersupplyispresent.ALogic“High”onthissignalshallindicatealossofAC

inputtothepowersupply.

Table12

ACOK#SignalCharacteristics

SignalType Pull-upto5Vsbthrougharesistorinthehost

system.

PRESENT#=Low Present

PRESENT#=High Notpresent

MIN MAX

Logiclevellowvoltage,Ising=4mA 0V 0.8V

Logiclevelhighvoltage,Isink=50µA 2.0V 4.80V

Sinkcurrent,PRESENT#=Low 4mA

Sourcecurrent,PRESENT#=High 50µA

PSON#SignalCharacteristic

SignalType Opencollector/drainoutputfrompower

supply.Pullupto5Vsbexternaltothepower

supply.

PWOK=High ON

PWOK=LOW OFF

MIN MAX

Logiclevellowvoltage,Isink=4mA 0V 0.8V

Logiclevelhighvoltage,Isource=200µA 2.0V 4.80V

Sinkcurrent,PWOK=low 4mA

Sourcecurrent,PWOK=high 2mA

PWOKdelay:Tpwokon 100msec 1000msec

PWOKriseandfalltime 100µsec

Powerdowndelay:Tpwokoff 1msec 1000msec

Rev. 02.22.11_81

HPS3000 Series

8 of 8

Embedded Power for

Business-Critical Continuity

 LEDINDICATORS

TherewillbeagreenPOWERLED(PWR)toindicatethatACisappliedtothe

PSUandstandbyvoltageisavailablewhenblinking.ThissameLEDshouldgo

solidwhenthe48Voutputisenabledandoperational.

TherewillbeanAmberPowerSupplyFailLED(FAIL)toindicatethatthepower

supplyhasfailedandareplacementoftheunitisnecessary.Faultsincluding

UVP,OVP,OTP,orFanFailwhenPSON#isasserted“LogicLow”shallcausethe

amberLEDtoturnon.TheLEDcanbeturnedoffbyrecyclingPSON#signalor

byanACpowerinterruptionmorethan1second.TheLEDshallbeoffwhen

PSON#isnotasserted“LogicLow”.Refertotable13forconditionsofthe

LED’s:

MTBF

ThepowersupplyhasaminimumMTBFof300KhoursusingtheBellcore332,

issue6specication@25°Cand40°C,ambient,atfullload.Withthepower

supplyinstalledinasystemina25°Cambientenvironmentand

operatingatfullload,capacitorlifeshallbe10years,minimumforALL

electrolyticcapacitorscontainedwithinthispowersupply.Thepowersupply

shalldemonstrateaMTBFlevelof>500,000hours.

Quality Assurance

FullQAVtestingshallbeconductedinaccordancewithEmersonNetwork

PowerStandardswithreportsavailableuponrequest.

Warranty

EmersonNetworkPowershallwarrantthepowersupplytobefreeofdefects

inmaterialsandworkmanshipforaminimumperiodoftwoyearsfromthe

dateofshipment,whenoperatedwithinspecications.Thewarrantyshallbe

fullytransferabletotheendowneroftheequipmentpoweredbythesupply.

Table13

LEDIndicators

Power Supply Condition Power LED

(GREEN)

Fail LED

(AMBER)

NoACpowertoPSU OFF OFF

ACpresent/StandbyOutputOn Blinking OFF

Powersupply48VoutputONandOK ON OFF

Powersupplyfailure(includes

overvoltage,overtemperature)

OFF ON

Current limit ON Blinking

Model Number Main Output Main Output

Current Standby Output Standby Current

HPS3000-9 48Vdc 62.0A 5.0V 3.0A

OrderingInformation

Americas

5810VanAllenWay

Carlsbad,CA92008

USA

Telephone:+17609304600

Facsimile: +17609300698

Europe(UK)

WaterfrontBusinessPark

MerryHill,Dudley

WestMidlands,DY51LX

UnitedKingdom

Telephone:+44(0)1384842211

Facsimile: +44(0)1384843355

Asia(HK)

14/F,LuPlaza

2WingYipStreet

KwunTong,Kowloon

HongKong

Telephone:+85221763333

Facsimile: +85221763888

Forglobalcontact,visit:

www.Emerson.com/

EmbeddedPower

techsupport.embeddedpower@

emerson.com

Whileeveryprecautionhasbeentakentoensure

accuracyandcompletenessinthisliterature,Emerson

NetworkPowerassumesnoresponsibility,anddisclaims

allliabilityfordamagesresultingfromuseofthis

information or for any errors or omissions.

EmersonNetworkPowerandtheEmerson

NetworkPowerlogoaretrademarksandser-

vicemarksofEmersonElectricCo.

EmersonNetworkPower.com

EmbeddedComputing

Embedded Power

Monitoring

OutsidePlant

PowerSwitching&Controls

PrecisionCooling

Racks&IntegratedCabinets

Services

SurgeProtection

EmersonNetworkPower.

Thegloballeaderinenabling

business-critical continuity.

ACPower

Connectivity

DC Power