Quadrax Contacts, Connectors and Cables Quadrax Contacts, Connectors and Cables Introduction Product Facts n 2 mm centerlines n Designed per ARINC 600 -- Supplement 18 n Fits into keyed connector inserts for connectors such as: ARINC 404 & 600, General Purpose Rectangular (GPR), MIL-DTL-38999 style, BACC65/EPXB, and custom interconnects nPatented single piece dielectric design simplifies termination and improves reliability n Size 8 contacts are designed for standard hex crimp per M2252/5-01 and M22520/5-45 n 24 AWG internal contacts are designed for crimp tooling M22520/2-01 and Daniels K-709 n Shells are keyed for proper orientation inside connector insert blocks n Rear Release/Rear Remove cable versions and Front Release/Front Remove PCB versions n Uses standard insertion/ extraction tool n Meets ASTM E595 outgassing limits for spacecraft materiels A multi-signal contact system consisting of two differential pairs (matched impedance) used with quadraxial Ethernet and Fibre Channel cables. Available in shell size 8 (keyed); 24 AWG pin and socket contacts, Hex Crimp version as well as pin PCB tail solderable versions. Adaptable to a variety of connectors (ARINC 600, 404, D-Subminiature connectors, MIL-DTL-38999 style, etc.) Designed for use in high speed applications such as Gigabit Ethernet, IEEE 802.3Z and Fibre Channel X3T11.2 for use on Commercial Avionics Systems, Aircraft Data Networks, Military Communications, In-Flight Entertainment, and Space applications. Materials Contacts, Shells, Ferrules -- Copper alloy with gold over nickel finish. One-piece thermoplastic dielectric. Performance Characteristics Maximum Mating Force per Contact Assembly -- 2.75 lbf. Minimum Un-mating Force per Contact Assembly -- 1.25 lbf. Durability -- 500 mating/ unmating cycles Typical Electrical Performance: Bandwidth - as high as 3 GHz (see characterization chart on page 3) Data Rate - in excess of 2 Gb/s Characteristic Impedance - 100 ohms 10 ohms Maximum Voltage Rating - 500 Vrms @ sea level Dielectric Withstanding Voltage - 1000 VAC rms between any two contacts @ sea level; 500 VAC rms between any contact and outer shell @ sea level Technical Documents Product Specifications 108-2131 Quadrax Cable and PCB Connectors 108-2199 Quadrax MIL-DTL-38999 Style Connectors 108-2311 Quadrax 4Q4 In-Line D-Sub Style Connectors Test Reports 501-574 Quadrax Cable and PCB Connectors 501-660 Quadrax MIL-DTL-38999 Style Connectors 501-738 Quadrax 4Q4 In-Line D-Sub Style Connectors 502-1182 Quadrax Rectangular Connector -- Qualified to Boeing Spec. BPS-C-193 Application Specifications 114-13123 Quadrax Rectangular Connectors and Quadrax Contacts 114-13163 Quadrax Circular Connectors and Quadrax Contacts 114-13190 In-Line Quadrax/Twinax Connectors 114-13233 Quadrax D-Sub Connectors and Quadrax Contacts 2 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Electrical Characteristics n Designed for use with 100 ohm and 150 ohm characteristic impedance star quad cable. Reference contact chart on page 10. n Signal integrity testing was completed per SFF-8410 (see engineering test report 502-1182). n Characteristic impedance: 100 ohm 10 ohm nominal (measured 102.85 ohms) n Near end cross talk (NEXT) in the time domain: 0.89% measured on Tek 11801C Digital Sampling Oscilloscope n Eye Patterns (Differential Mode, 1 meter and 11.2 meter cable test lengths) n The minimum output eye opening for a 1 V launch voltage measured at 50% of the period is: n1 meter, 100 MHz Eye Opening 928.53 mV n1 meter, 1.25 GHz Eye Opening 839.77 mV n11.2 meter, 100 MHz Eye Opening 761.60 mV n11.2 meter, 1.25 GHz Eye Opening 315.20 mV Return Loss Insertion Loss 1 Meter Cable Length Frequency MHz 50 62 102 502 1002 1954 2950 dB 34.33 36.03 40.21 21.21 13.34 9.32 10.27 1 Meter Cable Length VSWR* 1.039 1.032 1.02 1.191 1.549 2.039 1.884 11.2 Meter Cable Length Frequency MHz 50 62 102 502 1002 1798 2502 3702 dB 35.26 36.87 38.90 26.02 14.62 11.74 13.34 6.54 Frequency MHz 50 62 102 502 1002 2002 3002 dB 0.13 0.19 0.27 0.87 1.39 2.48 3.29 11.2 Meter Cable Length VSWR* 1.035 1.029 1.023 1.105 1.456 1.698 1.549 2.781 Frequency MHz 50 62 102 502 1002 1798 2502 3702 dB 1.87 2.13 2.72 6.38 10.06 15.69 19.47 28.20 *calculated Typical Insertion Loss 1 Meter Length, 100 Ohm Cable Eye Pattern, 100 Ohm Cable (Time Domain Measurement of Voltage vs. Time) 100 Mb/s Data Rate 1 Gb/s Data Rate 3 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Product Family Overview ARINC 600 Connectors: A Size 2 Plug Assembly with Q11 Quadrax Insert B Size 2 Receptacle Assembly with Q11 PCB Tail Quadrax Quadrax Rectangular Connectors: C 12 Position Receptacle D 12 Position Plug Assembly with Strain Relief and Seal Boots E 2 Position Plug Assembly with Strain Relief and Seal Boots F 2 Position Panel Mount Receptacle with Strain Relief and Seal Boots U Direct Attach 38999 Style Circular Connectors: I Size 19 Plug, 4Q4 Quadrax arrangement with Seal Boots J Size 19 Receptacle, 4Q4 Quadrax arrangement, Panel Mount Configuration w/Seal Boots K Size 19 Receptacle, 4Q4 Quadrax arrangement, PCB Mount L Size 9 Receptacle, 1Q1 Quadrax arrangement, Panel Mount w/Custom Flex Circuit Assembly for direct attachment to printed circuit board M Size 9 Plug, 1Q1 Quadrax arrangement with Seal Boot N Size 9 Receptacle, 1Q1 Quadrax arrangement, PCB Mount General Purpose Rectangular Connectors: G GPRB2 Plug, Dual Insert Configuration w/3 Pos. Quadrax Insert H GPRB2 Receptacle, Dual Insert Configuration w/3 Pos. Quadrax insert D-Sub Style Quadrax Rectangular Connectors: O Plug with Seal Boots P Receptacle, for right-angle PCB mount Q Receptacle, for vertical PCB mount R Cable Receptacle with Seal Boots 4 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Quadrax Contacts PC Tail Contacts Part No. Description 1445626-1 Contact, Pin, Solder Tail 1445626-3 Contact, Pin, Solder Tail 1445626-2 1445626-4 1445626-5* Dim. A .228 [5.79] Contact, Pin, Solder Tail .422 [10.72] Contact, Pin, Solder Tail .297 [7.54] .181 [4.60] Contact, Pin, Solder Tail .297 [7.54] Crimp Style Contacts1 Product Facts n n n n n n Patented one-piece dielectric inserts for easy assembly and lowest applied cost Available with silicone seal boots rated for 50,000 ft. altitude immersion Crimp type, screw machined, 24 AWG contacts Quadrax size 8 shells are keyed per ARINC 600 for correct orientation inside connector inserts n - One-piece dielectric inserts for easy assembly and lowest applied cost 1445692-4 *** Contact Kit, Pin, Crimp, with wire seal boot* 1445693-1 1445693-3** 1445693-4 **** Hex Crimp .218 Contact Kit, Pin, Crimp, with wire seal boot .218 -- Contact Kit, Socket, Crimp .218 Contact Kit, Socket, Crimp, with wire seal boot .218 Contact Kit, Socket, Crimp, with wire seal boot -- Reference cables: Tensolite NF24Q100, NF26Q100, 24443/03130X-4(LD), 24443/9P025X-4(LD); Raychem CEC-RWC-18687, Raychem CEC-RWC-18664 1445692-5** Contact Kit, Pin, Crimp with wire seal boot .218 1445693-5** Contact Kit, Socket, Crimp with wire seal boot .218 1445692-6 1445693-6 Contact Kit, Pin, Crimp .218 Contact Kit, Socket, Crimp .218 Reference cables: DRAKA F4703-3, F4704-4-insulation diameter is larger Hex Crimp 1877039-1 Contact Kit, Pin, Crimp .231 1877040-1 Contact Kit, Socket, Crimp .231 1877039-2** Direct Attach to PCB Internally keyed contacts for MIL-DTL-38999 connectors Description Contact Kit, Pin, Crimp 1445692-3** Twinax contacts: Qualification tests pending - Asymmetric standoff leg provides built-in keying to PC board Part No. 1445692-1 1877040-2** Contact Kit, Pin, Crimp with wire seal boot .231 Contact Kit, Socket, Crimp with wire seal boot .231 Reference cables: Tensolite 26473/02006X-4(LD); Raychem CEC-RWC-18684, Raychem CEC-RWC-18680 *Tails are solder dipped **Used with Quadrax rectangular and circular connectors ***Qualified to Boeing BACC47GA1 ****Qualified to Boeing BACC47GB1 (1) For other cables, contact TE. 5 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Quadrax Contacts (Continued) Size 8 Quadrax Contacts Part No. Description 1811010-1 Socket kit with heat-shrink tubing Hex Crimp .218 1811269-1 Pin kit with heat-shrink tubing .218 PC Tail Contact - Direct Attach to PCB Part No. Description Tail Length Dim A 1954576-1 150 Ohm .125 [3.18] .250 [6.35] 1954576-3 100 Ohm .205 [5.21] .270 [6.86] 1954576-2 100 Ohm .125 [3.18] .270 [6.86] Size 8 Differential Twinax Contacts Part No. Description Hex Crimp 1811865-1 Assembly, Pin, Twinax .218 1811866-1 Assembly, Socket, Twinax .218 See page 2 for Application Specifications 6 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Quadrax Contacts (Continued) Size 8 Quadrax PCB Pin Contact Front Release/ Front Remove Design Part No. 1445626-1ww O .313-.316 [7.95-8.03] Dim. A O .217-.219 [5.51-5.56] ww various tail lengths .079 .001 [2.00 0.03] O .273-.276 [6.93-7.01] Blank Front Release/ Front Remove Design Part No. 1604940-2 Size 8 Quadrax Pin Contact -- Crimp Style Rear Release/ Wiring Key Rear Remove Design (Index Line) Part No. 1445692-1w w -3 with boot O .217-.219 [5.51-5.56] O .313-.316 [7.95-8.03] Size 8 Quadrax Socket Contact -- Crimp Style Rear Release/ Rear Remove Design Part No. 1445693-1w w -3 with boot .505-.515 [12.82-13.08] O .313-.316 [7.95-8.03] .111 [2.82] O .248 [6.299] Ref. .056 [1.41] .665 Ref. [16.89] Quadrax Cable (not included, shown for reference only) Wiring Key (Index Line) O .287 [7.31] .111 [2.82] .056 [1.41] O .248 [6.299] Ref. .595 [15.11] .677 Ref. [17.2] Quadrax Cable (not included, shown for reference only) 7 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Quadrax Contacts (Continued) .020 Pin Position Feature Position 2 Cable shown for Illustration only; not included in kit .470 O .350.003 .155 .160 .125.015 PC Tail Contact - Direct Attach to PCB n 100 and 150 ohm Systems n Simple Direct Attach to PCB without connector for component reduction n Designed from ARINC size 8 Quadrax contacts n Low cost solution from both assembly and component ends Part Number 1954576-1, -2: B = .125 Part Number 1954576-3: B = .205 Part No. 1954576-1 1954576-2 1954576-3 Impedance () 150 100 100 Dim A (Max) .270 [6.86] .250 [6.35] .250 [6.35] Dim B .125 [3.18] .125 [3.18] .205 [5.21] Size 8 Differential Twinax Contacts 100 Ohm Differential Pair Twinax Contact n n Designed to meet the requirements of ARINC Specification 810 for 100 ohm size 8 non-concentric twin-axial contacts O .2179 Ref. [5.535] .510 Ref. [12.95] .665 Ref. [16.89] Wiring Key (Index Line) O .218 Ref. [5.53] O .3140 [7.976] Ref. .056 [1.41] Works in all connectors accepting ARINC 600 style Quadrax contacts O .2480 Ref. [6.299] Twinax Cable (not included, shown for reference only) .111 [2.82] Part No. 1811865-1 Wiring Key (Index Line) O .313-.316 [7.951-8.026] .056 Ref. [1.41] .595 Ref. [15.11] .677 Ref. [17.20] O .287 [7.31] Max. O .2480 Ref. [6.299] Twinax Cable (not included, shown for reference only) .111 [2.82] Part No. 1811866-1 8 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Quadrax/Twinax Contact Accessories Size 8 Quadrax Extraction Tool Part No. 1738894-1 1738894-1 Size 8 Removal Tool 1.50 [38.1] 1.28 [32.5] O .328 [8.3] O .283 [7.2] Seal Boots .82 [20.8] .82 [20.8] O .355 [9.0] O .275 [6.9] O .275 [6.9] .82 [20.8] O .355 [9.0] O .275 [6.9] .32 [8.1] .32 [8.1] Wire Seal Boot Part No. 1811481-1 Cable O.D. .145-.175 .218 Hex Crimp O .355 [9.0] O .275 [6.9] .32 [8.1] Wire Seal Boot Part No. 1811943-1 Cable O.D. .170-.200 .231 Hex Crimp 1.40 [35.36] O .275 [6.99] O .355 [9.02] .88 [22.35] Solid Seal Boot Part No. 1811633-1 9 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables ARINC Size 8 Quadrax Connectors Product Facts Utilizes four size 24 screw-machined contacts with standard crimp tooling per M22520/2-01 and M22520/5-01 for ease of termination Front release/front removable PCB mount contact design for use in ARINC 600 receptacle connectors Rear release/rear remove crimp contact design for use in ARINC ARINC Size 2 Connectors Part No. Type 600 plug connectors & receptacles Quadrax housing is keyed to assure mating alignment Contacts are on 2 mm centerline per ARINC 600 specification To extract Quadrax contact from connector insert, use Extraction Tool Part Number 1738894-1 Per Supplement 18 to ARINC Specification 600 Insert Arrangement A B C 1484406-2 Receptacle Q11 Q11 68Q2 1484407-2 Plug Q11 Q11 68Q2 1663032-1 Receptacle 150 150 11Q2 1663900-1 Receptacle Q11 Q11 85 1484620-1 Receptacle Q11 Q11 85 1484621-1 Plug Q11 Q11 85 ARINC Size 3 ConnectorsInsert Arrangement A B C Part No. Type D E F 150 150 11Q2 1663018-1 Receptacle 150 150 11Q2 150 150 11Q2 1663018-2 Receptacle 150 150 11Q2 1663018-3 Receptacle 1663019-1 Plug 1663019-2 Plug 1663019-3 Plug 150 150 150 150 150 150 150 150 150 150 150 150 150 150 150 150 Style Shell Features Contacts Front Release Front Remove Rear Release Rear Remove Front Release Front Remove Front Release Front Remove Front Release Front Remove Rear Release Rear Remove Electroless Nickel Plated, no clinch nuts Electroless Nickel Plated, no clinch nuts Chromate with six 4-40 clinch nuts Chromate, no clinch nuts Electroless Nickel Plated, with ten 4-40 clinch nuts Electroless Nickel Plated, no clinch nuts Size 22 signal & Quadrax contacts supplied loaded in inserts; post extension = .25 [6.35] Crimp style size 22 signal and Quadrax contacts supplied unloaded Signal, Power and Quadrax contacts supplied loaded in inserts; post extension = .25 [6.35] Signal, Power and Quadrax contacts supplied loaded in inserts; post extension = .25 [6.35] Signal, Power and Quadrax contacts supplied loaded in inserts; post extension = .15 [3.81] Crimp contacts Style Shell Features Contacts Front Release/ Front Remove Front Release/ Front Remove Electroless Nickel Plated No contacts 11Q2 11Q2 11Q2 11Q2 11Q2 11Q2 11Q2 11Q2 Front Release Front Remove Rear Release Rear Remove Rear Release Rear Remove Rear Release Rear Remove Chromate with fourteen 6-32 clinch nuts Signal, Power and Quadrax contacts supplied loaded in inserts; post extension signal and power = .25 [6.35]; Quadrax = .200 [5.08] Signal, Power and Quadrax contacts supplied loaded in inserts, post extension = .25 [6.35] Electroless Nickel Plated No contacts Electroless Nickel Plated Crimp contacts Chromate Crimp contacts Electroless Nickel Plated Note: Custom insert combinations available upon request. Contact TE. 6.960 .015 [176.78 0.38] 68Q2 Insert Assembly 6.980 .015 [177.29 0.38] 11Q11 Insert Assembly 68Q2 Insert Assembly 11Q11 Insert Assembly 1.800 .010 [45.72 0.25] Date Code Keying Plate and Screws Shell .650 [16.51] Receptacle, Assembly Size 2 Front Release/Front Remove Part No. 1484406-2 shown 1.800 .010 [45.72 0.25] Keying Plate and Screws Shell .650 [16.51] Plug, Assembly Size 2 Rear Release/Rear Remove Part No. 1484407-2 shown 10 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables ARINC Size 8 Quadrax Connectors (Continued) Contact Inserts & Arrangement Codes -- Shell Size 2 or 3 Shell Module A, B, D or E Q11 1, 2, 3 11 Size 8 Quadrax Metal Shell Module C or F Q6 1, 2, 3 6 Size 8 Quadrax Metal 11Q2 1, 2, 3 4 Size 20 4 Size 12 3 Size 16 2 Size 8 Quadrax 68Q2 2, 3, 4 68 Size 22 2 Size 8 Quadrax A 1 Notes: 1. Available for plug or receptacle with rear release/ remove contacts. 2. Available for receptacle only with all contacts front release/remove. 3. Standard size 8 contacts will not fit in Quadrax size 8 inserts. Also, Quadrax size 8 contacts will not fit into standard size 8 inserts. 4. Available for plug only with all contacts rear release/remove. 118Q2 118Q2 118 Size2,3, 22 4 2 118 Size 8 Quadrax Size 22 2 Size 8 Quadrax 13CQ2 2, 3 4 Size 20 3 Size 16 4 Size 12 2 Size 8 Quadrax 62Q2 2, 3, 4 60 Size 22 2 Size 16 2 Size 8 Quadrax For complete listing of all ARINC 600 insert arrangements, reference catalog 1308940. GPRB Insert Arrangements1,2 Keying: A 25QI 3 10Q2 3 B 3Q3 3 27.00 max. max.)Mating Pin (1.063 inserts: Notes: 1 . faces shown above. 2. In a GPRB2 shell, one insert must be "A" keyed and the other one must be "B" keyed (See at right). 3. Size 8 cavity applicable for use with Arinc 600 Quadrax or Twinax contacts. For complete listing of all General Purpose Rectangular insert arrangements, reference catalog 1654763. 27.50 max. (1.083 max.) 11 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Rectangular Connectors Product Facts High performance rectangular connector Available in 2, 4, and 12 positions Designed for use with wire seal boots and rated for use up to 50,000 ft. altitude Center jackscrew design for fast, reliable mating Position 2 4 Aluminum shells are keyed and polarized, and are available with lightweight plastic backshell strain reliefs Provides excellent density in a rectangular profile for packaging flexibility. Qualified to Boeing Part Standard BPS-C-193 Part No. 1604896-2* 1604897-5* 1604898-5* Type Receptacle Receptacle Plug Mounting Style PCB Panel Mount Free-Hanging Style Front Release/Front Remove Rear Release/Rear Remove Rear Release/Rear Remove Polarization Flat Flat Flat 1604905-1* Backshell - (1 pc) -- -- -- 1738949-2* 1738950-2* 1738951-2* Receptacle Receptacle Plug PCB Panel Mount Free-Hanging Front Release/Front Remove Rear Release/Rear Remove Rear Release/Rear Remove Flat Flat Flat 1738955-1* Backshell - (1 pc) -- -- -- PCB Panel Mount Free-Hanging -- -- Front Release/Front Remove Rear Release/Rear Remove Rear Release/Rear Remove -- -- Flat Flat Flat -- -- 1604798-2* Receptacle 1604799-5* Receptacle 1604800-5* Plug 1604874-1* Backshell - Receptacle (2 pc) 1604874-2* Backshell - Plug (2 pc) 12 Note: Use w/1604897-5 or 1604898-5 Use w/1738950-2 or 1738951-2 Use w/1604799-5 Use w/1604800-5 *Jackscrew/Jackpost hardware included but not installed 2 Position 2.160 [54.86] 1.949 [49.5] 1.905 [48.39] 1.694 [43.03] 1.694 .010 [43.03 0.25] .790 .003 [20.0 0.08] .125 [3.18] 2X 1.333 .002 [33.9 0.05] .344 [8.74] 1.333 .003 [33.86 0.08] .672 +.001/-.002 [17.1 +0.03/-0.05] .750 .003 [19.1 0.08] 6-32 SPIRALOCK Threads Thru, 4X 1.221 .002 [31.01 0.06] 1.569 .010 [39.9 0.25] .422 [10.7] 1.445 .010 [36.70 0.25] .225 [5.72] Jackscrew and Retention Nut Kit, Part Number 1738592-2. Included, but not installed. Jackpost and Retention Nut Kit, Part Number 1738592-1. Included, but not installed. PCB Mount Receptacle (Part No. 1604896) 1.309 [33.2] 1.070 [27.18] 6-32 SPIRALOCK Threads Through 2X .965 .010 [24.5 0.25] 1.217 +.001/-.003 [30.9 +0.03/-0.08] Panel Mount Receptacle (Part No. 1604897) Free-Hanging Plug (Part No. 1604898) SPIRALOCK is a trademark of Detroit Tool Industries Corporation. 12 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Rectangular Connectors (Continued) 4 Position 1.949 [49.50] 1.685 [42.80 1.25 [31.75] 2X Ref. 2.160 [49.50] 1.905 [48.39] .010 0.25] .001 1.217 +- .003 + 0.03 [30.91 - 0.08 ] 1.694 [43.03] .865 .003 [21.97 0.08] 1.333 [33.86 .350 .002 [8.89 0.05] .002 0.05] 1.070 [27.18] 2X 6-32 UNC-2B SPIRALOCK Threads Through .344 [8.74] 1.221 .002 [31.01 0.05] .825 .003 [20.96 0.08] 6-32 SPIRALOCK Threads Through, 4X 1.333 .003 [33.86 0.08] 1.221 .002 [31.01 0.05] .965 .010 [24.51 0.25] .250 .003 [6.35 0.08] 1.309 [33.25] 1.569 .010 [39.85 0.24] .422 [30.72] 1.445 .010 [36.70 0.25] .225 [5.72] Jackscrew and Retention Nut Kit, Part Number 1738592-2. Included but not installed. Jackpost and Retention Nut Kit, Part Number 1738592-1. Included, but not installed. PCB Mount Receptacle (Part No. 1738949) Panel Mount Receptacle (Part No. 1738950) Free-Hanging Plug (Part No. 1738951) 12 Position 3.600 [91.4] 3.600 [91.4] 3.346 .010 [85.0 0.25] 3.346 [84.99] 2.960 [75.2] .630 [16.0] .790 .003 [20.0 0.08] .125 [3.18] 2X 2.984 .002 [75.8 0.06] .965 [24.5 .750 .003 [19.1 0.08] .900 .003 [22.9 0.08] 6-32 SPIRALOCK Threads Through 2X .010 0.25] 2.868 +.001/-.003 [72.8 +0.03/-0.08] 2.872 .002 [72.95 0.05] 2.984 .003 [75.8 0.08] .672 +.001/-.002 [17.1 +0.03/-0.05] 6-32 SPIRALOCK Threads Thru, 4X 1.569 .010 [39.9 0.25] Jackscrew and Retention Nut Kit, Part Number 1738592-2. Included but not installed. 1.445 [36.70] Jackpost and Retention Nut Kit, Part Number 1738592-1. Included, but not installed. PCB Mount Receptacle (Part No. 1604798) Panel Mount Receptacle (Part No. 1604799) Free-Hanging Plug (Part No. 1604800) SPIRALOCK is a trademark of Detroit Tool Industries Corporation. 13 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Rectangular Connectors (Continued) Accessories 2 Position Low Profile Seal Retainer Part No. 2101752-1 4 Position Low Profile Seal Retainer Part No. 2157322-1 ORIENTATION OF BOOT SEAL PLATE FOR PLUG APPLICATION ORIENTATION OF BOOT SEAL PLATE FOR PLUG APPLICATION 12 Position Backshell/ Strain Relief Kit Part No. 1996373-1 for receptacle; Part No. 1996373-2 for plug 12 Position Low Profile Seal Retainer Part No. 1996544-2 Wrench, Retention Nut, Jackscrew and Jackpost, Quadrax Rectangular Connector Part No. 1604972-1 Wrench, Retention Nut, T-handle Tool Part No. 1950030-1 14 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Rectangular Connectors (Continued) Low Profile Rectangular Connector Assemblies Product Facts n Designed to provide a ruggedized in-line solution for Quadrax cable to printed circuit board mount applications, in a blind-mateable D-subminiature configuration n Quadrax contacts ground directly to connector shell 4Q4 Outer Contact Shell Brass Plated Gold Over Nickel Dielectric Thermoplastic 1.852 [47.0] 1.534 [39.0] .329 [8.4] Strain Relief Clamp Thermoplastic Packaged Unassembled 1.852 [47.0] Interfacial Seal Fluorosilicone 1.512 .003 [38.40 0.08] .504 [12.8] 2.607 [66.2] REF .312 .003 [7.92 0.08] #4-40 UNC SPIRALOCK 2X 2.088 [53.0] Receptacle Shell Nickel Plated Aluminum Alloy .504 [12.8] O.120.003 [3.050.08] 2X Receptacle Shell Nickel Plated Aluminum Alloy .296.002 [7.52.05] #4-40 Jackscrew Stainless Steel Qty. 2 .296 [7.5] 2.088 [53.0] .130 [3.3] #4-40 UNC SPIRALOCK 2X Nickel Plated Aluminum Alloy 1.740 [44.2] .379 [9.6] .550 [14.0] .504 [12.8] 1.852 [47.0] Interfacial Seal Fluorosilicone Right Angle PCB Mount Receptacle (Part No. 2000314) Panel-Mount or Free-Hanging Plug Kit (Part No. 2000317) Free-Hanging Receptacle Kit (Part No. 2000263) Accepts standard AMPLIMITE Boardlock Hardware (sold separately). Socket Contacts included in Kit. Accepts standard AMPLIMITE Screwlock Hardware (sold separately). Jackscrews, Strain Relief, and Crimp Pin Contacts included in kit. Female Screwlock Part No. 212447-1 Nut Driver Part No. 811262-1 For assembling female screwlocks to connector flange. 15 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom MIL-DTL-38999 Series III Style Circular Connectors Product Facts Available in various shell sizes: 9 (1Q1), 17 (2Q2), 19 (4Q4) and 25 (8Q8) Designed for use with wire seal boots for sealing and optimized alignment Front metal-shell design provides a full ground plane Lightweight composite rear shell available in size 19 for reduced weight Accepts standard backshells Shell Size 9 17 19 21 23 25 Part No. 1877384 1738916 1811184 2157694 1877775 1877774 2157455 2157695 1811902 1738974 1877732 1811901 2157696 1954355 1954353 1877921 1954577 1811928 1811927 2101395 Type Plug Receptacle Receptacle Receptacle Plug Receptacle Receptacle Receptacle Plug Receptacle Receptacle Receptacle Receptacle Plug Receptacle Plug Receptacle Plug Receptacle Receptacle Description Single Quadrax, RR-RR 38999 Style, Single Quadrax, FR-FR, Jam Nut Style, with PC Tail Contacts 38999 Style, Single Quadrax, FR-FR, PCB Mount with Stand-offs and PC Tail Contacts 38999 Style, Single Quadrax, with 1 Contact, FR-FR, Jam Nut Style, Series III 38999 Style, Arrangement 2Q2, RR-RR 38999 Style, Arrangement 2Q2, RR-RR 38999 Style, Arrangement 2Q2, FR-FR, PCB Mount 38999 Style, with 2 Quadrax Contacts, Arrangement 2Q2, FR-FR, Jam Nut Style, Series III 38999 Style, Arrangement 4Q4, RR-RR 38999 Style, with 4 Quadrax Contacts, FR-FR 38999 Style, with 4 Quadrax Contacts, FR-FR, with PC Tail Contacts 38999 Style, Arrangement 4Q4, RR-RR 38999 Style, with 4 Quadrax Contacts, Arrangement 2Q2, FR-FR, Jam Nut Style, Series III 38999 Style, Arrangement 4Q4, FR-FR, Series III 38999 Style, Arrangement 4Q4, FR-FR, Series III, with PC Tail Contacts 38999 Style, Arrangement 6Q6, Series III 38999 Style, Arrangement 6Q6, Series III 38999 Style, Arrangement 8Q8, RR-RR 38999 Style, Arrangement 8Q8, RR-RR 38999 Style, Arrangement 8Q8, FR-FR, with PC Tail Contacts See TE Customer Drawing for finish options Plug, Shell Size 9 Single Quadrax, RR-RR Part No. 1877384 O.855 [21.72] Max. Over Knurl O .429 [10.90] O .520 [13.21] O .727 [18.47] .020 [.508] Receptacle, Shell Size 9, 38999 Style Single Quadrax, FR-FR Jam Nut Style Part No. 1738916 1.064 [27.03] 1.527 [38.79] O 1.185 [30.10] 1.064 [27.03] Contacts sold separately (unless noted) see page 5 .885 [22.48] .662 [16.81] .425 [10.79] 16 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom MIL-DTL-38999 Series III Style Circular Connectors (Continued) Receptacle, Shell Size 9, 38999 Style Single Quadrax, FR-FR PCB Mount with Stand-offs Part No. 1811184 (with PC tail contacts) .937 .72 [18.29] [23.8] .72 [18.29] .818 [20.78] .329 [8.36] .16 [4.06] 6-32 UNF .25 Deep 4X Receptacle, Shell Size 9 38999 Style Single Quadrax, FR-FR Jam Nut Style Part No. 2157694 Plug, Shell Size 17, 38999 Style Arrangement 2Q2, RR-RR Part No. 1877775 O1.513 [38.43] Max. Over Knurl .379 [9.63] Ref. 1.210 [30.73] O 1.270 [32.26] O .748 [19.0] O 0.917 [23.29] .022 [0.56] Receptacle, Shell Size 17 38999 Style Arrangement 2Q2, RR-RR Part No. 1877774 1.062 [26.97] .969 [24.61] .752 [19.1] Ref. 1.232 [31.29] .818 [20.76] .132 [3.34] 1.311 .010 [33.3 0.25] O .748 [19.00] O 1.183 [30.05] .090 [2.29] 1.590 [40.39] Ref. Contacts sold separately (unless noted) see page 5 .683 [17.34] Ref. 17 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom MIL-DTL-38999 Series III Style Circular Connectors (Continued) Receptacle, Shell Size 17 38999 Style Arrangement 2Q2, FR-FR Part No. 2157455 .400 [10.16] Typ .818 [20.76] .805 [20.45] 2X 1.311 .010 [33.30 .25] .185 [4.70] .185 [4.70] .604 [15.24] .000 O .062 1.57 Ref. 1.096 [27.84] Typ .060 [1.52] .470 [11.94] .100 [2.54] .509 [12.93] .096 [2.44] Ref. Receptacle, Shell Size 17 38999 Style Arrangement 2Q2, FR-FR Jam Nut Style Part No. 2157695 Plug, Shell Size 19 38999 Style Arrangement 4Q4, RR-RR Part No. 1811902 O1.513 [38.42] Max. Over Knurl O 1.376 [34.95] O .840 [21.34] O 1.022 [25.96] .020 [0.51] Receptacle, Shell Size 19, 38999 Style w/4 Quadrax Contacts, FR-FR Part No. 1877732 (w/ PC Tail Contacts) .380 [9.64] Ref. 1.210 [30.73] .75 [19.04] Ref. 1.156 [29.36] 1.156 [29.36] Part No. 1738974 (connector only) O 1.244 [31.60] 1.435 [36.45] 6-32 UNF .25 Deep 4x .818 [20.76] .118 [3.00] .400 [10.16] Contacts sold separately (unless noted) see page 5 18 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom MIL-DTL-38999 Series III Style Circular Connectors (Continued) Receptacle, Shell Size 19, 38999 Style Arrangement 4Q4, RR-RR Part No. 1811901 1.156 [29.36] 1.232 [31.29] .132 [3.34] 4X 1.062 [26.97] 1.435 [36.45] .818 [20.76] O .840 [21.34] O 1.244 [31.60] .683 [17.34] Ref. .090 [2.29] 1.590 [40.39] Ref. Receptacle, Shell Size 19 38999 Style Arrangement 4Q4, FR-FR Jam Nut Style Part No. 2157696 Plug, Shell Size 21, 38999 Style Arrangement 4Q4, FR-FR Series III Part No. 1954355 Receptacle, Shell Size 21, 38999 Style Arrangement 4Q4, FR-FR Series III Part No. 1954353 1.250 Typ. [31.75] .315 [8.00] .200 [5.08] 1.499 Typ. [38.07] Plug, Shell Size 23, 38999 Style Arrangement 6Q6, Series III Part No. 1877921 1.72 1.72 [43.69] [43.69] Max. Over Knurl Max. Over Knurl Contacts sold separately (unless noted) see page 5 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com .818 [20.78] 1.210 1.210 [30.73] [30.73] .024 .024 [0.61] [0.61] Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 .298 [7.57] .379 .379 [9.63] [9.63] .750 .750 [19.05] [19.05] Ref. Ref. Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 19 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom MIL-DTL-38999 Series III Style Circular Connectors (Continued) Receptacle, Shell Size 23, M38999 Style Arrangement 6Q6, .156 Typ. Series III [3.96] Part No. 1954577 Plug, Shell Size 25 38999 Style Arrangement 8Q8, RR-RR Part No. 1811928 1.689 .010 Typ. [42.90 0.25] 1.590 Typ. [40.39] 1.375 Typ. [34.93] .818 [20.78] 1.250 Typ. [31.75] O 1.887 [47.92] Max. Over Knurl .090 [2.29] 1.665 .818 [42.29] [20.8] .40 Typ [10.16] .805 8 Plc. 1.811.010 [46.0.25] Typ .604 [15.34] O1.746 [44.35] O 1.397 [35.48] O 1.400 [35.36] 1.620 [41.15] Typical .816 [20.73] .014 [0.36] Receptacle, Shell Size 25 38999 Style Arrangement 8Q8, RR-RR Part No. 1811927 .470 [11.94] 1.500 [38.1] 1.500 Typ [38.1] 1.375 [34.93] .060 [1.52] 1.666 [42.32] .097 Ref [2.46] .10 .090 [2.54] .818 [20.76] .156 [3.96] 1.811 .010 [46.0 0.25] .509 [12.93] O 1.620 [41.15] O 1.397 [35.48] .818 [20.8] Receptacle, Shell Size 25 38999 Style Arrangement 8Q8, FR-FR Part No. 2101395 (w/ PC Tail Contacts) .759 [19.27] [2.29] .40 Typ [10.16] .805 8 Plc. 1.811.010 [46.0.25] Typ .604 [15.34] 1.620 [41.15] Typical 1.500 [38.1] Typ .470 [11.94] .060 [1.52] .509 [12.93] .10 [2.54] Receptacle, Shell Size 25 38999 Style Arrangement 8Q8 Jam Nut Part No. 2157628 .097 Ref [2.46] Contacts sold separately (unless noted) see page 5 20 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables QUADLITE Quadraxial Cables Product Facts 00 ohm and 150 ohm 1 cables Materials rated from -65C to +200C Low outgassing materials (PTFE, FEP) Custom design capabilities Proven technologies and materials Lightweight Low smoke and low toxicity Available in 150C and 200C rated construction TE's Quadlite family of lightweight, fluoropolymer cables are for use in high speed, high bandwidth applications such as 100Base-T, Gigabit Ethernet, IEEE 1394 and Fibre Channel employed in commercial avionics systems, aircraft data networks, in-flight entertainment systems and military communications. Applications Materials Cables are used in communications, control and instrumentation for: n In-Flight Entertainment n Satellite TV n Flight Subsystems n Military Communications Dielectrics -- Foamed FEP Jacket -- FEP Standards and Specifications TE Specification 1200 ANSI/TIA-568-B.2 IEEE 1394 ARINC 664 The Quadlite cables are designed to meet the flammability requirements of FAR Part 25 and the rigorous smoke and toxicity requirements found in commercial aerospace standards such as EN3475. Quadlite cables are to be used with the Quadrax contacts and connectors. 21 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables QUADLITE Quadraxial Cables (Continued) 100Base-T Ethernet Cables 100 Ohms - 150C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 1 MHz 10 MHz 100 MHz Min. NEXT (dB) Min. SRL (dB) TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 1 MHz 10 MHz 100 MHz Min. NEXT (dB) Min. SRL (dB) CEC-RWC-18634 26 SCCA 0.0185 Formed FEP 0.037 0.145 17.7 TCC FEP 100 150C 13.5 CEC-RWC-18664 24 SCCA 0.0235 Formed FEP 0.042 0.154 20.3 TCC FEP 100 150C 13.0 CEC-RWC-18666 22 SCC 0.0295 Formed FEP 0.057 0.195 32.0 TCC FEP 100 150C 12.9 4.0 10.5 36.0 2.2 6.8 24.8 1.6 5.9 21.0 10 MHz 50 23 100 MHz 35 16 10 MHz 50 23 100 MHz 35 16 CEC-RWC-20555 26 SCCA 0.0185 Formed FEP 0.037 0.144 18.7 TCC FEP 100 150C 13.5 CEC-RWC-20333 24 SCCA 0.0235 Formed FEP 0.042 0.153 22.2 TCC FEP 100 150C 13.0 4.0 10.5 36.0 2.2 6.8 24.8 10 MHz 50 23 100 MHz 35 16 10 MHz 50 23 10 MHz 50 23 100 MHz 35 16 100Base-T Ethernet 100 MHz 35 16 22 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables QUADLITE Quadraxial Cables(Continued) 100Base-T Ethernet Cables 100 Ohms - 200C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 1 MHz 10 MHz 100 MHz Min. NEXT (dB) Min. SRL (dB) CEC-RWC-18658 26 SCCA 0.0185 Formed FEP 0.037 0.144 18.7 SCC FEP 100 200C 13.5 CEC-RWC-18687 24 SCCA 0.0235 Formed FEP 0.042 0.153 22.2 SCC FEP 100 200C 13.0 CEC-RWC-18665 22 SCC 0.0295 Formed FEP 0.057 0.194 34.3 SCC FEP 100 200C 12.9 4.0 10.5 36.0 2.2 6.8 24.8 1.6 5.9 21.0 10 MHz 50 23 100 MHz 35 16 10 MHz 50 23 100 MHz 35 16 10 MHz 50 23 100 MHz 35 16 23 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables QUADLITE Quadraxial Cables (Continued) Fibre Channel Cables 150 Ohms - 150C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 531 MHz 1062 MHz CEC-RWC-18680 26 SCCA 0.0185 Formed FEP 0.058 0.193 23.4 TCC FEP 150 150C 6.0 CEC-RWC-18681 24 SCCA 0.0235 Formed FEP 0.077 0.224 38.3 TCC FEP 150 150C 6.0 CEC-RWC-18682 22 SCC 0.0295 Formed FEP 0.094 0.281 57.2 TCC FEP 150 150C 6.0 13 21 11 17 9 13 CEC-RWC-18684 26 SCCA 0.0185 Formed FEP 0.058 0.192 25.8 SCC FEP 150 200C 6.0 CEC-RWC-18685 24 SCCA 0.0235 Formed FEP 0.077 0.247 38.3 SCC FEP 150 200C 6.0 CEC-RWC-18686 22 SCC 0.0295 Formed FEP 0.094 0.284 57.2 SCC FEP 150 200C 6.0 13 21 11 17 9 13 150 Ohms - 200C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 531 MHz 1062 MHz Fibre Channel 24 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables QUADLITE Quadraxial Cables (Continued) 4-Pair Cat 5E Constructions 100 Ohms - 150C/200C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 1 MHz 100 MHz 100 MHz Min. NEXT (dB) Min. SRL (dB) CEC-RWC-20412 24 SCHSCA 0.0235 Formed FEP 0.046 0.279 46.2 TCC FEP 100 150C 13.5 CEC-RWC-21064 24 SCC 0.0235 Formed FEP 0.046 0.249 39.5 TCC XL-ETFE 100 150C 13.5 CEC-RWC-20638 26 (7 strand) SCC 0.019 Formed FEP 0.036 0.204 29.8 SCC FEP 100 200C 13.5 2.4 7.5 26.4 2.2 6.8 24.8 2.4 8.8 30.5 10 MHz 50 25 100 MHz 35 19 10 MHz 50 25 100 MHz 35 19 10 MHz 50 23 100 MHz 35 16 Cat 6 Constructions 100 Ohms - 100C/90C TE Part No. Conductor AWG Size (19 Strand) Conductor Material: Nom. Conductor Diameter (in.): Insulation Material: Nom. Insulation OD 0.002 (in.): Nom. Cable OD (in.): Nom. Cable Weight (lb/1 kft): Shield Material: Jacket Material: Impedance 10% (): Temp. Rating: Nom. Capacitance (pF/ft): Nom. Attenuation (dB/100 m): 1 MHz 100 MHz 100 MHz 250 MHz Min. NEXT (dB) Min. SRL (dB) CEC-RWC-20837 23 Bare Copper 0.021 Foamed PE 0.046 0.350 52.6 TCC FDR-25 100 100C 13.5 CEC-RWC-21088 23 Bare Copper 0.021 PE 0.046 0.249 39.5 TCC Raythane 100 90C 13.5 1.8 5.5 18.3 30.4 1.8 5.5 18.3 30.4 10 MHz 70 36 250 MHz 52 24 10 MHz 70 36 250 MHz 52 24 25 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Custom Solutions Spacecraft Applications Product Facts Custom Cable and Flex Assemblies Product Facts General Purpose Rectangular (GPR) Connector Assemblies Product Facts n n n (See Catalog 1654763) This product is sold by TE under license from Radiall S.A. Single Splice Quadrax Part No. 1996500 Quadrax contacts and QUADLITE cables meet ASTM E595 outgassing limits for spacecraft applications Quadrax contacts and connectors can be provided as custom cable and flex assemblies for customer specific applications Quadrax inserts are available for the rugged, modular General Purpose Rectangular connector, facilitating the mix of high speed signals with a variety of other power, fiber optic, signal, and coax insert configurations in a single connector system Product Facts n Provides field repairable splicing mechanism n Ideally suited for a Quadrax cable production break where space is limited Contact TE for additional information on any of these custom solutions. 26 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 Quadrax Contacts, Connectors and Cables Part Number Index Part No. Page Note: This index lists all cataloged parts by base no. only. Complete part nos. (with prefixes and/or suffixes) are shown on the page(s) indicated. Part No. CEC-RWC-18634 CEC-RWC-18664 CEC-RWC-18666 CEC-RWC-20555 CEC-RWC-20333 CEC-RWC-18658 CEC-RWC-18687 CEC-RWC-18665 CEC-RWC-18680 CEC-RWC-18681 CEC-RWC-18682 CEC-RWC-18684 CEC-RWC-18685 CEC-RWC-18686 CEC-RWC-20412 CEC-RWC-21064 CEC-RWC-20638 CEC-RWC-20837 CEC-RWC-21088 1445626 1445692 1445693 1484406 1484407 1484620 1484621 1604798 1604799 1604800 1604874 1604896 1604897 1604898 1604905 Page Part No. 22 22 22 22 22 23 23 23 24 24 24 24 24 24 25 25 25 25 25 5, 7 5, 7 5, 7 10 10 10 10 12, 13 12, 15 12, 13 12 12 12 12 16 1604940 1604972 1663018 1663019 1663032 1663900 1738592 1738894 1738916 1738949 1738950 1738951 1738955 1738974 1811010 1811184 1811269 1811481 1811633 1811865 1811866 1811901 1811902 1811927 1811928 1811943 1877039 1877040 1877384 1877732 1877774 1877775 1877921 1950030 Page 14 10 10 10 10 12, 13 9 16 12, 13 12, 13 12, 13 12 16, 18 6 16, 17 6 9 9 6, 8 6, 8 16, 19 16, 18 16, 20 16, 20 9 5 5 16 16, 18 16, 17 16, 17 16, 19 14 7 Part No. Page 1954353 1954355 1954576 1954577 1996373 1996500 1996544 2000314 2000317 2000263 2101395 2101752 212447 2157322 2157455 2157694 2157695 2157696 811262 16, 19 16, 19 6, 8 16, 20 14 26 14 15 15 15 16, 20 14 15 14 16, 18 16, 17 16, 18 16, 19 14 27 Catalog 1654012 Revised 2/12 Dimensions are in inches (mm) unless otherwise specified. www.te.com Dimensions are shown for reference purposes only. Specifications subject to change. USA: +1 (800) 522-6752 Canada: +1 (905) 475-6222 Mexico/C. Am.: +52 (0) 55-1106-0800 Latin/S. Am.: +54 (0) 11-4733-2200 Germany: +49 (0) 6251-133-1999 UK: +44 (0) 800-267666 France: +33 (0) 1-3420-8686 Netherlands: +31 (0) 73-6246-999 China: +86 (0) 400-820-6015 FOR MORE INFORMATION Technical Support Internet: USA: Canada: Mexico: C. America: South America: Germany: Great Britain: France: Netherlands: China: www.te.com/ADM +1 (800) 522-6752 +1 (905) 470-4425 +52 (0) 55-1106-0814 +52 (0) 55-1106-0814 +55 (0) 11-2103-6000 +49 (0) 6251-133-1999 +44 (0) 8706-080208 +33 (0) 1-3420-8686 +31 (0) 73-6246-999 +86 (0) 400-820-6015 Follow us on Twitter for all the latest product news @TEConnectivity, and on Facebook, TEConnectivity. www.te.com/ADM (c) 2012 Tyco Electronics Corporation. All Rights Reserved. 1654012 ADM 5M 02/2012 TE Connectivity, and the TE connectivity (logo) are trademarks of the TE Connectivity Ltd. family of companies. Other products, logos, and company names mentioned herein may be trademarks of their respective owners. While TE has made every reasonable effort to ensure the accuracy of the information herein, nothing herein constitutes any guarantee that such information is error-free, or any other representation, warranty or guarantee that the information is accurate, correct, reliable current. The TE entity issuing this publication reserves the right to make any adjustments to the information contained herein at any time without notice. All implied warranties regarding the information contained herein, including, but not limited to, any implied warranties of merchantability or fitness for a particular purpose are expressly disclaimed. The dimensions herein are for reference purposes only and are subject to change without notice. Specifications are subject to change without notice. Consult TE for the latest dimensions and design specifications.