5mm LED CBI(R) Circuit Board Indicator Sloped Back Housing, Quad Block 550-xx07-004 PART NO. 25 [.984] 6.35 [.250] 2.97 [.117] 9.01 [.355] A 5.97 [.235] 550-0207-004 550-0307-004 550-0407-004 4.69 [.185] 3.0 [.118] 550-0507-004 550-0707-004 550-0807-004 5.2 [.205] 2.54 [.100] 6.35 [.250] Red, 5V Green, 5V Yellow, 5V LOW CURRENT RECOMMENDED P.C. HOLE PATTERN 550-1107-004 550-1207-004 550-1307-004 Dimension A: 3.4 [.135] for -0207 to -0407, 4.95 [.195] for all others Dimension B: .635 [.025] for -0507 to -0707, .508 [.020] for all others Hole Diameter: 1.22 [.048] for .635 [.025] leads, 1.02 [.040] for all others Dimensions in mm [inches] Red Yellow Green HIGH EFFICIENCY 550-2207-004 550-2307-004 550-2407-004 550-2507-004 Standard Polarity shown in drawing: Cathode right Features * Multiple CBIs form horizontal LED arrays on 6.35mm (0.250") center-lines. * * * * * Green Yellow Red INTEGRAL RESISTOR B CATHODE Red Cathode for Red/Green Bi-Color Yellow Cathode for Yellow/Green Bi-Color 2.54 [.100] COLOR* GENERAL PURPOSE CATHODE ID Green Yellow Red Orange BI-COLOR High Contrast, UL 94 V-0 rated, black housing Oxygen index: 32% Polymer content: PBT, 0.680 g Housing stand-offs facilitate PCB cleaning Solderability per MIL-STD-202F, method 208F 550-3007-004 550-3107-004 Red/Green Yellow/Green SUPER BRIGHT, DIFFUSED 550-5107-004 550-5207-004 550-5307-004 * LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 * Compatible with: Red Green Yellow SUPER BRIGHT, WATER CLEAR (Non-tinted, Non-diffused) 550-5507-004 550-5607-004 550-5707-004 550-xx07 Single-Block 550-xx07-002 Dual-Block Custom Combinations Red Green Yellow * LED 1, LED 2, LED 3, LED 4 * Contact factory for information on custom color combinations Reverse Polarity (Cathode Left) option available. See Part Number Ordering Code. Tolerance note: As noted, otherwise: * LED Protrusion: 0.04 mm [0.016] * CBI Housing: 0.02mm[0.008] Series PART NUMBER ORDERING CODE Polarity Option 0 - Standard Cathode Right LED Type 1 - Reverse Cathode Left 5 5 0 - x x 0 7 - 0 x 4 Quad Block 6-34 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com NEW 550-xx07-004 Typical Operating Characteristics (TA=25C) GENERAL PURPOSE See LED data sheet for additional information See page 6-55 and 6-56 for Reference Only LED Drive Circuit Examples. See page 6-58 for Pin Out Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-0207-004 550-0307-004 Green Yellow 565 585 12.3 12.3 2.1 2.1 20 20 60 60 5ND-9674 5ND-9673 6-51 6-51 550-0407-004 Red 635 12.3 2 20 60 5ND-9672 6-51 Color Peak Wavelength nm IV mcd Test Voltage Forward Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-0507-004 Red 655 2 5 13 60 5RD-9422 6-52 550-0707-004 550-0807-004 Green Yellow 565 583 8 8 5 5 12 10 60 60 5RD-9423 521-9284 6-52 6-41 Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-1107-004 550-1207-004 550-1307-004 Red Yellow Green 635 583 565 2 1.8 1.8 1.8 1.9 1.8 2 2 2 50 50 50 521-9320 521-9321 521-9327 6-42 6-42 6-42 INTEGRAL RESISTOR Part Number LOW CURRENT HIGH EFFICIENCY Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-2207-004 550-2307-004 Green Yellow 563 585 10 6.3 2.1 2.1 10 10 65 50 5HD-9270-5 5HD-9271-5 6-49 6-49 550-2407-004 550-2507-004 Red Orange 650 600 7 7 2.2 1.9 10 10 50 60 5HD-9269 521-9704 6-49 6-43 Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 660/565 585/565 90/40 8.7/8.7 1.8/2.1 2.1/2.1 20 20 60 50 521-9651 521-9724 6-46 6-46 BI-COLOR Part Number 550-3007-004 Red/Green 550-3107-004 Yellow/Green SUPER BRIGHT, DIFFUSED Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-5107-004 550-5207-004 550-5307-004 Red Green Yellow 650 563 585 34 34 34 2.1 2.2 2.2 20 20 20 50 50 50 5SD-9441 5SD-9456 5SD-9455 6-53 6-53 6-53 SUPER BRIGHT, WATER CLEAR (NON-TINTED, NON-DIFFUSED) Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2 1/2 LED Data sheet Page # 550-5507-004 550-5607-004 550-5707-004 Red Green Yellow 635 565 583 125 120 140 2.2 2.3 2.2 20 20 20 24 24 24 521-9464 521-9465 521-9466 6-47 6-47 6-47 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-35 6 5mm Discrete LED Integral Resistor, 5 Volts Diffused 9.19 [.362] 8.43 [.332] .76 [.030] 521-9183, -9284 PART NO. 521-9183 521-9284 5.84 [.230] .64 [.025] LED COLOR Red Yellow 2.54 [.100] 5.08 [.200] 4.57 [.180] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow ABSOLUTE MAXIMUM RATINGS (TA=25C) -9183 -9284 Forward Voltage (V) Derating (V/C) From 50C 7.5 .071 7.5 .071 Operating Temperature (C) -40/+85 -40/+85 Storage Temperature (C) -55/+100 -55/+100 Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Luminous Intensity (mcd) Min. VF = 5V Typical Red Yellow -9183 2 8 -9284 2 8 Peak Wavelength (nm) Peak Typical 635 583 Viewing Angle (2 1/2) Typical 60 60 Forward Current (I) VF = 5V Typical Max 10 15 10 15 Min. 5 5 Reverse Voltage (V), IR=100A 6 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-41 5mm Discrete LED Low Current, 2mA Diffused 8.81 [.347] .76 [.030] 521-9320, -9321, -9327 PART NO. 521-9320 521-9321 521-9327 5.84 [.230] .46 [.018] 2.54 [.100] 4.83 [.190] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX COLOR Red Yellow Green CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow Green -9320 -9321 -9327 Power Dssipation (mW) Derating (mA/C) From 92C 27 1 36 1 24 1 Forward Current (mA) 7 7 7 Peak Current (mA) Pulse width = 10 s 500 500 500 Operating Temperature (C) -55/+100 -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Yellow Green -9320 -9321 -9327 Luminous Intensity (mcd) IF=2mA Min. Typical 1.2 2 1.2 1.8 1.2 1.8 Peak Wavelength (nm) Peak Typical 635 583 565 Viewing Angle (2 1/2) Typical 50 50 50 Forward Voltage (V) IF=2mA Typical Max. 1.8 2.2 1.9 2.7 1.8 2.2 Reverse Voltage (V), IR=50A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-42 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Discrete LED High Efficiency Diffused 8.81 [.347] .76 [.030] 521-9246, -9248, -9250, -9704 PART NO. 521-9246 521-9248 521-9250 521-9704 5.84 [.230] .46 [.018] 2.54 [.100] 4.83 [.190] 1.0 [.040] MAX 1.27 [.050] COLOR Red Yellow Green Orange CATHODE 25.1 [1.00] MIN MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow Green Orange ABSOLUTE MAXIMUM RATINGS (TA=25C) -9246 -9248 -9250 -9704 Power Dissipation (mW) Derating (mW/C) From 25C 1. (mA/C) From 50C 135 1.8 85 1.6 135 1.8 135 .51 Forward Current (mA) 25 20 25 30 Peak Current (mA) 500 500 500 500 Operating Temperature (C) -55/+100 -55/+100 -20/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 -55/+100 Pulse width = 10s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Yellow Green Orange -9246 -9248 -9250 -9704 Luminous Intensity (mcd) IF=10mA Min. Typical 4 7 4 8 4.2 5.2 4 7 Peak Wavelength (nm) Peak Typical 635 583 565 600 Viewing Angle (2 1/2) Typical 60 60 60 60 Forward Voltage (V) IF=10mA Typical Max. 2.2 3 2.2 3 2.3 3 1.9 2.4 Reverse Voltage (V), IR=100A Min. 5 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-43 6 5mm Discrete LED Bi-Color Non-Tinted, Diffused 8.64[.340] 1.50 [.059] MAX 521-9651, -9724 5.59 [.220] 0.51 [.020] 5.00 [.197] 2.54 [.100] 22.1 [.87] MIN. 1.00 [.04] Dimensions in mm [inches] PART NO. LED COLOR 521-9651 Red/Green 521-9724 Yellow/Green CATHODE GREEN, RED/GREEN BI-COLOR 521-9651 CATHODE YELLOW, YELLOW/GREEN BI-COLOR 521-9724 MOUNTING CLIP: 515-0005 located on page 6-48 Red/Green Yellow/Green -9651 -9724 100/100 60/100 40/30 .5/.4 20/30 .25/.40 200/120 80/120 Operating Temperature (C) -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Forward Current (mA) Derating (mA/C) From 50C Peak Current (mA) Pulse width = 100 s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red/Green Yellow/Green -9651 -9724 Luminous Intensity (mcd) IF=20mA Min. Typical 29/12.6 90/40 2.5/2.5 8.7/8.7 Peak Wavelength (nm) Peak Typical 660/565 585/565 Viewing Angle (2 1/2) Typical 60 50 Forward Voltage (V) Typical 1.8/2.1 2.1/2.1 Max. 2.4/2.8 2.8/2.8 IF=20mA is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-46 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Discrete LED Super Bright, Water Clear Non-Tinted, Non-Diffused 8.81 [.347] 1.0 [.040] MAX 521-9464,-9465,-9466 5.84 [.230] 4.83 [.190] 2.54 [.100] 25.35 [.998] MIN 1.27 [.050] TYP CATHODE .46 [.018] SQ. Dimensions in mm [inches] ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Derating (mW/C) From 25C 1. From 50 C PART NO. COLOR 521-9464 521-9465 521-9466 Red Green Yellow MOUNTING CLIP: 515-0004 located on page 6-48 Red Green Yellow -9464 -9465 -9466 135 1.8 135 1.8 85 1.61 Forward Current (mA) 30 30 20 Peak Current (mA) Pulse width = 10 s 500 500 500 Operating Temperature (C) -55/+100 -20/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 Soldering Temperature 260 C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Green Yellow -9464 -9465 -9466 Luminous Intensity (mcd) IF=20mA Min. Typical 80 125 80 120 80 140 Peak Wavelength (nm) Peak Typical 635 565 583 Viewing Angle (2 1/2) Typical 24 24 24 Forward Voltage (V) IF=20mA Typical Max. 2.2 3 2.3 3 2.2 3 Reverse Voltage (V), IR=100A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-47 6 5mm High Efficiency Diffused 5HD-xxxx TYPE *5HD-9269 *5HD-9270-2 *5HD-9270-5 *5HD-9271-2 *5HD-9271-5 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25C) COLOR Red Green Green Yellow Yellow Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 60 1 .66 140 75 1 .66 200 60 1 .66 Forward Current (mA) Derating (mA/C) From 25C 20 40 .6 25 60 .8 20 Peak Current (mA) 60 500 60 1000 60 Operating Temperature (C) -25/+85 -55/+100 -25/+85 -55/+100 -25/+85 Storage Temperature (C) -30/+100 -55/+100 -30/+100 -55/+100 -30/+100 Power Dissipation (mW) Derating (mW/C) From 50C 1. From 40C Pulse width = 1s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 Luminous Intensity (mcd) IF=10mA Min. Typical 2.2 7 4 32 3.6 10 4 10 2.2 6.3 Peak Wavelength (nm) Peak Typical 650 565 563 590 585 Viewing Angle (2 1/2) Typical 50 50 65 70 50 Forward Voltage (V) I F=10mA, *IF=20mA Typical Max. 2.2 2.5 2* 2.6* 2.1 3 2.4* 3* 2.1 3 Reverse Voltage (V), IR=100A *IR=10A Min. 5 5* 3* 5* 3 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-49 6 5mm General Purpose Diffused 5ND-xxxx TYPE COLOR *5ND-9672 *5ND-9673 *5ND-9674 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red Yellow Green Red Yellow Green -9672 -9673 -9674 Power Dissipation (mW) 80 60 100 Forward Current (mA) Derating (mA/C) From 25C 40 .5 20 .25 30 .4 Peak Current (mA) 200 80 120 Operating Temperature (C) -55/+100 -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Pulse width = 10 s Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red Yellow Green -9672 -9673 -9674 Luminous Intensity (mcd) IF=20mA Min. Typical 3.5 12.3 3.5 12.3 3.5 12.3 Peak Wavelength (nm) Peak Typical 635 585 565 Viewing Angle (2 1/2) Typical 60 60 60 Forward Voltage (V) IF=20mA Typical Max. 2 2.8 2.1 2.8 2.1 2.8 Reverse Voltage (V), IR=100A Min. 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-51 6 5mm Integral Resistor Diffused 5RD-xxxx TYPE *5RD-9378 *5RD-9379 *5RD-9422 *5RD-9423 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25C) COLOR Green Yellow Red Green VOLTS 12 12 5 5 Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 15* 15 7.5 7.5 Operating Temperature (C) -20/+85 -40/+85 -40/+85 -20/+85 Storage Temperature (C) -55/+100 -55/+100 -55/+100 -55/+100 Forward Voltage (V) *(TA=70C) Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 Luminous Intensity (mcd) VF=5V, *VF=12V Min. Typical 1.5* 4* 1.5* 4* 1 2 2 8 Peak Wavelength (nm) Peak Typical 565 583 655 565 Viewing Angle (2 1/2) Typical 60 60 60 60 Forward Current (mA), VF=5V *VF=12V Typical Max. 13* 20* 13* 20* 13 20 12 15 Reverse Voltage (V), IR=100A Typical 5 5 5 5 is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-52 Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 5mm Super Bright LED Diffused 5SD-xxxx TYPE *5SD-9441 *5SD-9455 *5SD-9456 COLOR Red Yellow Green * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red -9441 Yellow -9455 Green -9456 75 75 75 25 .66* 25 .5 25 .5 60 60 60 Operating Temperature (C) -55/+100 -55/+100 -55/+100 Storage Temperature (C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25C) Power Dissipation (mW) Forward Current (mA) Derating (mA/C) From 50C *(mW/C) From 40C Peak Current (mA) Pulse width = 1 ms Soldering Temperature 260C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25C) Red -9441 Yellow -9455 Green -9456 Luminous Intensity (mcd) IF=20mA Min. Typical 17 34 17 34 17 34 Peak Wavelength (nm) Peak Typical 650 585 563 Viewing Angle (2 1/2) Typical 50 50 50 Forward Voltage (V) IF=20mA Typical Max. 2.1 2.55 2.2 3 2.2 3 Reverse Voltage (V), IR=10A Min. 3 3 3 is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation * 1501 Route 34 South * Farmingdale, NJ 07727 * TEL: (732) 919-3119 * FAX: (732) 751-5778 *www.dialight.com 6-53 6