Embedded Power for Business-Critical Continuity Rev. 10.18.07 LPQ350 Series 1 of 3 LPS350 Series 350 Watts Total Power: 350 Watts Input Voltage: 85-264 Vac 120 - 300 Vdc # of Outputs: Single Special Features * Active power factor correction * IEC EN61000-3-2 compliance * Remote sense on * Power fail and remote inhibit * Single wire current sharing * Built-in EMI filter * Adjustable floating 4th output * 2 Supervisory output 5 V and 12 V * Overvoltage protection * Overload protection * Thermal overload protection * DC power good * 130 KHz switching frequency * Optional with fan cover -CF * Cover -C * Optional end-mounted fan -CEF Safety VDE 0805/EN60950 (IEC950) 21310-3336-0001 UL UL1950 EI86249 CSA CSA 22.2-234 Level 5 LR109492C NEMKO EN 60950/EMKO-TUE P98102115 (74-sec) 203 BABT EN60950/BS7002 608857, 608858, 609097 CB Certificate and report 5734, 6280, 6281 CE Mark (LVD) Electrical Specifications Input Input range 85 - 264 VAC; 120 - 300 VDC Frequency 47 - 440 Hz Inrush current 38 A max, cold start @ 25 C Efficiency EMI filter 75% typical at full load FCC Class B conducted and radiated CISPR 22 Class B conducted and radiated EN55022 Class B conducted and radiated VDE 0878 PT3 Class B conducted and radiated Power factor Safety ground leakage current 0.99 typical 0.5 mA @ 50/60 Hz, 264 VAC input Output Maximum power With cover: 350 W with 30 CFM forced air, (-C) (-CF) (-CEF) Adjustment range 2:1 wide ratio Supervisory output 5 V @ 500 mA regulated, 12 @ 150 mA x2 Hold-up time Overload protection 0 ms @ 350 W load, 115 VAC nominal line at factory voltage settings 2 Short circuit protection on all outputs. Case overload protected @ 110 - 145% above peak rating Overvoltage protection 5 V output: 5.7 - 6.7 VDC. Other models 10% to 25% above nominal output Embedded Power for Business-Critical Continuity Rev. 10.18.07 LPQ350 Series 2 of 3 Logic Control Power failure TL logic signal goes high 50 - 150 msec after 5 V output. It T goes low at least 4 msec before loss of regulation Remote on/off Requires an external contact (N.O or N.C) to inhibit outputs DC-OK TTL logic goes high 50 - 150 msec after 5 V output. It goes low when there is loss of regulation Remote sense ompensates for 0.5 V lead drop min. Will operate without C remote sense connected. Reverse connection protected Environmental Specifications Operating temperature: Storage temperature: 0 to 50C ambient; derate each output at 2.5% per degree from 50 to 70 C -40 C to +85 C Pin Assignments Temperature coefficient: 0.4% per C Electromagnetic Designed to meet IEC 801, -2, -3, -4, -5, -6, Level 3 susceptibility: Humidity: Operating; non-condensing 5% to 95% Vibration: MTBF demonstrated: Three orthogonal axes, sweep at 1 oct/min, 5 min. dwell at four major resonances 0.7 G peak 5Hz to 500Hz, operational > 550,000 hours at full load and 25 C ambient conditions SK1 PIN 1 PIN 2 PIN 3 SK3 PIN 1 PIN 2 PIN 3 PIN 4 PIN 5 PIN 6 PIN 7 PIN 8 PIN 9 PIN 10 SK4 PIN 1 Ordering Information LPS352-C 5 V (3 - 6 V) LPS353-C 12 V (6 - 12 V) 0A 0A Maximum Load with Convection Cooling 70 A 29.2 A LPS354-C 15 V (12 - 24 V) 0A LPS355-C 24 V (24 - 48 V) 0A Model Number Output Voltage Minimum Load Peak Load 1 Regulation 2 Ripple P/P (PARD)3 SK5 PIN 2 PIN 1 SK6 PIN 2 PIN 1 80 A 33 A 2% 2% 50 mV 120 mV 23.3 A 26 A 2% 150 mV 14.6 A 16 A 2% 240 mV 1. Peak current lasting < 30 seconds with a maximum 10% duty cycle. 2. At 25 C including initial tolerance, line voltage, load currents and output voltages adjusted to factory settings. 3. Peak-to-peak with 20 MHz bandwidth and 10 F in parallel with a 0.1 F capacitor at rated line voltage and load ranges. 4. 4th output 3.3 - 24 V factory set at 5 V.If optional CF or CEF fans are not used, 30CFM forced air cooling needs to be provided and is required through the length of the power supply. Not convection rated. 5. Output voltage adjustment requires a 1A load. 6. Remote inhibit resets OVP latch. Note: -CF suffix added to the model number indicates cover with fan, -CEF suffix added to model number indicates end-mounted fan chassis. PIN 2 Neutral Line Ground N/C N/C + Sense - Sense POK C. Share DC - OK Inhibit (N.O.) Inhibit (N.C.) COM + Fan 1 (12V@150mA) - Common + 5V aux (5V@100mA) - Common + Fan 2 (12V@150mA) - Common Mating Connectors SK3 Molex: 22-01-1104 PINS: 08-70-0057 SK4 Molex 22-01-3027 PINS: 08-50-0114 SK5 Molex 22-01-3027 PINS: 08-50-0114 SK6 Molex 22-01-3027 PINS: 08-50-0114 Astec Connector Kit #70-841-011, includes all of the above. Embedded Power for Business-Critical Continuity Rev. 10.18.07 LPQ350 Series 3 of 3 Mechanical Drawing Americas 6-32 (2 places) Main Output Terminal Block TB1 +ve -ve M3 (4 places) M3 (6 places) SK3 #6-32 UNC (8 places) .24 (6.1) 1 2 3 4 5 6 7 8 9 10 J1 SK5 (5V aux) SK4 Fan Europe (UK) 3.68 (93.6) SK6 Fan Waterfront Business Park Merry Hill, Dudley West Midlands, DY5 1LX United Kingdom Telephone: +44 (0) 1384 842 211 Facsimile: +44 (0) 1384 843 355 5.46 (138.6) 6.64 (168.6) (-CF) Cover with fan 3.15 (80) 8.52 (216.4) 9.0 (228.6) 10.78 (273.8) 2.17 (55) 6-32 (3 places) 3 2 1 SK1 5.0 (127.0) .55 (14) .79 (20) 5810 Van Allen Way Carlsbad, CA 92008 USA Telephone: +1 760 930 4600 Facsimile: +1 760 930 0698 Optional (-CEF) Cover with fans 1.18 (30.0) Asia (HK) 14/F, Lu Plaza 2 Wing Yip Street Kwun Tong, Kowloon Hong Kong Telephone: +852 2176 3333 Facsimile: +852 2176 3888 For global contact, visit: www.Emerson.com/EmbeddedPower 2.5 (63.5) 3.5 (88.9) 1.30 (33.0) 3.42 (87.0) techsupport.embeddedpower @emerson.com While every precaution has been taken to ensure accuracy and completeness in this literature, Emerson Network Power assumes no responsibility, and disclaims all liability for damages resulting from use of this information or for any errors or omissions. Emerson Network Power. The global leader in enabling business-critical continuity. AC Power Connectivity DC Power Notes: 1. Specifications subject to change without notice. 2. All dimensions in inches (mm), tolerance is .02". 3. Specifications are at factory settings 4. To enable normally closed Remote Inhibit, cut jumper J1. 5. Mounting maximum insertion depth is 0.12". 6. Warranty: 2 year 7. Weight: 3.6 lb. / 1.64 kg. Embedded Computing Embedded Power Monitoring Outside Plant Power Switching & Controls Precision Cooling Racks & Integrated Cabinets Services Surge Protection EmersonNetworkPower.com Emerson Network Power and the Emerson Network Power logo are trademarks and service marks of Emerson Electric Co. (c)2010 Emerson Electric Co.