Sach Nr.: DATENBLATT / Specification K-Nr.: 22279 K-no.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE Datum: 30 A - Stromsensor Modul / Current Sensor Module 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 1 von 7 of Mabild siehe Blatt 2 : Mechanical outlines page 2 Anschluschema: Schematic diagram i1 10 + UB + 5...8 9 ia + + Ra Ca 1...4 11 - UB M Betriebsdaten/Charakteristische Daten (Richtwerte): Operational data/characteristic data (nominal values): Nennstrom i1Neff = 3...31 A iaNeff = 1,5...15,5 mA KN = 1...4 : 2000 I1max = 92 A IBo < 18 mA UB = 15 V 5% UBtot = 18 V Ri < 220 Ra = 20...250 TU = -40...+85 C 70 40 92 20 85 31 92 20 C A A Rated current Nennausgangsstrom Output current Nennubersetzungsverhaltnis Transformation ratio Uberstrom (Ra <20 )) Over current (Ra < 20 ) Versorgungsstrom im Leerlauf supply current Versorgungsspannung Supply voltage Maximale Versorgungsspannung (ohne Fkt.) Maximum supply voltage (without function) Innenwiderstand Interal resistance Abschluwiderstandsbereich Load resistance Umgebungstemperatur Ambient temperature Maximum Ratings: Maximum Ambient Temperature: Maximum RMS-Current: Maximum Peak-Current: Output Resistor (all primary current bars in parallel) Housing and bobbin material UL-listed Applicable documents: Hrsg.: editor Name Le Bd. KB-E 60 50 92 20 Gehause- und Spulenkorperwerkstoff UL-gelistet. Weitere Vorschriften: Datum 27.10.09 30.08.04 50 54 92 20 Index 81 81 Anderung Anschlufeld Seite 2: Stiftabmessung fur Stifte 9-11 von 0,5x1,0 korrigiert in 0,7x0,6mm. Schreibfehler. Umgebungstemperatur: Unterer Grenzwert von -10 auf -40 korrigiert. Lapidaranderung. Bearb: Ma. KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. Sach Nr.: DATENBLATT / Specification K-Nr.: 22279 K-no.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE Datum: 30 A - Stromsensor Modul / Current Sensor Module 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 2 von Mabild (mm): Freimatoleranz DIN ISO 2768-c Anschlusse: Mechanical outline General tolerances Connections: 2,77 2x2,54 1 9 10 11 7,0 1,95 3,85 14,5 1...8: 1 mm 9...11: 0,7x0,6 mm Toleranz der Stiftabstande 0,3mm (Tolerances grid distance) 4 7 of 11,4 8 5 4,5 2,54 7,62 18,0 Beschriftung: 33 marking 4644X400 F DC 25,2 F DC 0,5 3,5 3,50,5 0,7x0,6 O1,0 DC=Date Code F=Factory Prufung: (V: 100%-Test; AQL...: DIN ISO 2859-Teil1) Inspection 1) (V) Ausgangsstrom (Ra =100 ) ia (20 A) = 10 mA 0,5 % IO 0,05 mA Up,eff = 4 kV, Output current (Ra = 100 ) 2) (V) Offsetstrom Offset current 3) (V) M3014*: 1s *Die Spannungsfestigkeit gilt am separaten Bauelement zwischen den Stiften 1...8 und den Stiften 9...11. The dielectric strength is valid between pin 1...8 and pin 9...11. Messungen nach Temperaturangleich der Pruflinge an Raumtemperatur Measurements after temperature balance of the samples at room temperature Hrsg.: editor KB-E Bearb: Ma. KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. Sach Nr.: DATENBLATT / Specification K-Nr.: 22279 K-no.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE Datum: 30 A - Stromsensor Modul / Current Sensor Module 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 3 von 7 of Connections variants N4644-X400 N,1 i 1,RMS I1 i a,RMSf Wdg. A A mA 1 40 2 20 4 10 92 46 23 20 20 20 KN Ra F ges F ges Beschaltung (i 1RMS) (i 1RMS/2) connection % % Ohm 1 : 2000 2 : 2000 4 : 2000 20 1 20 4 8 1 5 4 8 1 5 4 8 5 1,5 1 20 1 1,5 1 1,5 Maximal mebarer Strom i1 (Ra) Maximum measurable current i1(Ra) i1 100,0 A 90,0 80,0 70,0 60,0 50,0 40,0 0,0 Hrsg.: editor KB-E 20,0 Bearb: 40,0 Ma. 60,0 80,0 KB-E B: Le 100,0 120,0 KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten 140,0 160,0 180,0 200,0 220,0 Ohm 240,0 Ra freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. DATENBLATT / Specification K-Nr.: K-no.: Sach Nr.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE 22279 Datum: 30 A - Stromsensor Modul / Current Sensor Module 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 4 von 7 of Charakteristische Daten (Richtwerte) des Stromsensormoduls ermittelt durch eine Typprufung General data ascertained by type test Megenauigkeit bei Raumtemperatur Fi < 0,5 % FLi < 0,1 % FTi < 0,1 % f = DC...100 kHz < 1 s Verzogerungszeit bei i1max bei einem Stromanstieg von di/dt = 100 A/s t (i1max, 100 A/s) < 1 s Measuring accuracy at room temperatur Linearitat Linearity Temperaturdrift von Fi (-40...+70C) Temperature drift of Fi (-40...+70C) Frequenzbereich (bei eingeschrankter Amplitude) Frequency range (with limited amplitude) Ansprechzeit Response time Delay time at i1max with a current rise of di/dt = 100 A/s Offsetstrom (beinhaltend Io, Iot, IoT) Ioges < 0,1 mA Offsetstrom bei Raumtemperatur Io < 0,05 mA Iot < 0,05 mA IoT < 0,05 mA IoH < 0,05 mA ioss < 3 mA Io/UB < 0,01 mA/V Ck < 5 pF TL = -40 ... +70C m < 15 Offset current (including Io, Iot, IoT) Offset current at room temperature Drift von Io Offset current drift Temperaturdrift von Io (-40...+70C) Offset current temperature drift (-40...+70C) Hysterese von Io Hysteresis of Io Offsetripple (s.Blatt 5) Offset ripple (s. page 5) Versorgungsspannungsdurchgriff auf Io Supply voltage rejection ratio Maximal mogliche Koppelkapazitat primar - sekundar (bei nichtisoliertem das Innenloch voll ausfullendem Primarleiter) Maxiimum possibble coupling capacitance (primary - secondary) (with not isolated the the hole completely filling primary conductor Lagertemperaturbereich Storage temperature range Masse g Masse Spannungsfestigkeit (gultig nach EN 50178 VDE0160, fur Isolierklasse I, Verschmutzungsgrad 2 und verstarkte Isolierung) Dielectric strength (with EN 50178 VDE0160: material group I, pollution degree 2, reinforced insolution) Anwendungsklasse nach EN 60721 5K3 (Applicability tested by IEC 68-2-30: test Db) Stromrichtung: Ein positiver Mestrom erscheint am Anschlu ia, wenn der Primarstrom in Pfeilrichtung fliet. Current direction: A positiv output current appears at point ia by primary current in direction of the arrow. Hrsg.: editor KB-E Bearb: Ma. KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. Sach Nr.: DATENBLATT / Specification K-Nr.: K-no.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE 22279 30 A - Stromsensor Modul / Current Sensor Module Datum: 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 5 von 7 of Weitere Vorschriften: Applicable documents: Konstruiert, gefertigt und gepruft nach VDE0160 EN 50178 und erfullt die Vorschriften. Parameter: Verstarkte Isolierung: Pin1...Pin8 gegen Pin9...Pin11 Verschmutzungsgrad 2 Bemessungsisolationsspannung UDC = 1 kV Isolierstoffklasse 1 Constructed, manufactured and tested in accordance with VDE0160 EN 50178 and agrees with the standards. Parameters: Reinforced insulation Pin1...Pin8 to Pin9...Pin11 Pollution degree 2 Rated insulation voltage UDC = 1 kV Insulation material group 1 Gehause, Spulenkorperwerkstoff und Gieharz UL gelistet Housing, bobbin material and casting resin UL-listed. Typprufung: Type test 1) Stospannungsprufung in Anlehnung an M3064 HV transient test according to M3064 Pin1...Pin8 gegen Pin9...Pin11 Pin1...Pin8 to Pin9...Pin11 Einstellwerte: 1,2 s / 50 s-Kurvenform UP,max = 9 kV Ri = 60 Settings (waveform) 10 Impulse im Abstand t = 10 Sekunden mit wechselnder Polaritat 10 pulses in a cycle of t = 10 seconds with changing polarity 2) M3024: Up,eff = 4 kV, 60 s, Pin1...Pin8 gegen Pin9...Pin11 Pin1...Pin8 to Pin9...Pin11 UTA,eff Hrsg.: editor KB-E Bearb: Ma. 750 V KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. DATENBLATT / Specification K-Nr.: K-no.: Sach Nr.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE 22279 30 A - Stromsensor Modul / Current Sensor Module Datum: 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 6 von 7 of Mogliche Offsettripple-Verringerung durch Tiefpa: Avariable offset ripple reduction means of a low pass: Der Offsettripple kann durch einen externen Tiefpa verringert werden . Dazu mu parallel zu Ra eine Kapazitat Ca geschaltet werden. Die Abbildung zeigt den verbleibenden Wert des Offsetripples (ioss(Ra . Ca)) bezogen auf den Wert ohne externe Kapazitat (ioss). Hierbei wird allerdings die Ansprechzeit verlangert. Sie berechnet sich nach der Formel: The offset ripple can be reduced by an external low pass. Therefore a capacitance Ca must be switched parallel to Ra. The diagram shows the remaining value . of the offset ripple (ioss(Ra Ca)) relative to the value without external capacitance (ioss). In this case the response time is lengthened. It is calculated from: 1 a + 2,5 Ra Ca . . bzw. fg = -------------------2 . Ra . Ca ioss (Ra . Ca) Beispiel: -------------------- = 10% Example: ioss Ra = 100 ; Ca = 27 nF a 6,8 s; fg = 17 kHz 100.0 Ioss(Ra*Ca) Ioss 10.0 [%] 1.0 0.1 1 10 100 Ra*Ca [us] Hrsg.: editor KB-E Bearb: Ma. KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages. DATENBLATT / Specification K-Nr.: K-no.: Sach Nr.: T60404-N4644-X400 Item no.: V AC U UM SC H M ELZE 22279 30 A - Stromsensor Modul / Current Sensor Module Datum: 27.10.2009 Date: Kunde: Kd. Sach Nr.: Seite Customer Customers part no.: Page 7 von 7 of Erlauterung einiger in den Tabellen verwendeter Groen (alphabetisch) Explanation of several of the terms used in the tablets (in alphabetical order) aKrit: Abstand eines storstromfuhrenden Leiters von der Gehauseseitenflaache, bei dem auch an ungunstiger Stelle die zugeordnete Storgroe am Ausgang des Sensos 1% des Nennstroms nicht ubersteigt. Den Angaben liegt ein sinusformiger Storimpuls mit einer Impulsbeite von 50 s in Hohe des Nennstroms zugrunde. Distance of a current carring conductor from the sides of the housing, where even at the most unfavourable spot the applicable interference at the sensor output does not exeed 1% of rated current. The data is based on a sinusoidal interference pulse current with a pulse width of 50 s having the same magnitude as the rated current. Fges(i1): Die Summe aller moglichen Fehler im gesamten Temperaturbereich bei der Messung eines Stroms i1: The sum of all possible errors over the temperature range when measuring a current i1: ia (i1) 100 .* ---------------- - 1 KN . i1 In der Ausgangsprufung zugelassener Mefehler bei RT, definiert durch Fges = Fi: Permissible measurement error in the final inspection at RT, defined by Ia Fi = 100 * ----------- - 1 iaNeff wobei Ian der offsetbereinigte Ausgangsgleichstromwert fur einen Eingangsgleichstrom in Hohe des (positiven) Nennstroms ist (d.h. Io = 0 ) where Ian is the output DC value of an input DC current of the same magnitude as the (positive) rated current (Io = 0) FLi: I1 Ia FLi = 100 * --------- - --------- Linearity fault defined by I1Neff Ian Dabei ist I1 beliebiger Eingangsgleichstrom und Ia die zugehorige offsetbereinigte Ausgangsgroe (d.h. Io = 0). Ian Linearitatsfehler definiert durch s. Erlauterung zu Fi. Where I1 is any input DC and Ia the corresponding output term. Ian see notes of Fi (Io = 0). FTi: Temperaturdrift der nennwertbezogene Ausgangsgroen Ian (vgl. Erlauterung zu Fi) im spezifischen Temperaturbereich, gegeben durch. Temperatur drift of the rated value orientated output term. Ian (cf. Notes on Fi) in a specified temperature range, obtained by: Ian (TU2 ) - Ian (TU1) FTi = 100 *.------------------------------------- iaNeff IaSt: Ausgangsgleichstrom hervorgerufen durch einen Storgleichstrom in Hohe des Nennstroms in einem Leiter in 1 cm Abstand von der Gehauseseitenflache (ungunstige Lage). Output DC current caused by an interfering DC current of the same magnitude as the rated current in a conductor 1 cm away from the sides of the housing (unfavourable position). IoH: Nullpunktabweichung nach Ubersteuerung mit Gleichstrom des 4-fachen Nennwerts. (Ra = RaN) Zero variaton after overloading with a DC of fourfold the rated value. (Ra = RaN) Iot: Langzeitdrift von Io nach 100 Temperaturwechseln im Bereich von -40 bis 85 C. Long term drift of Io after 100 temperature cycles in the range -40 to 85 C. : Ansprechzeit, gemessen als Verzogerungszeit bei i1 = 0,9 . i1 zwischen einem eingespeisten Rechteckstrom und dem dazugehorigen Ausgangsstrom. Response time, measured as delay time at i1 = 0,9 t (i1max, 100 A/s): . i1 between a rectangular current i1 and the output current ia Verzogerungszeit zwischen i1max und dem dazugehorigen Ausgangsstrom ia bei einem Stromanstig des Primarstroms von di1/dt = 100 A/s. Delay time between i1max and the output current ia with a primary current rise of di1/dt = 100 A/s. Hrsg.: editor KB-E Bearb: Ma. KB-E B: Le KB-PM B: Ga. designer check check Weitergabe sowie Vervielfaltigung dieser Unterlage, Verwertung und Mitteilung ihres Inhalts nicht gestattet, soweit nicht ausdrucklich zugestanden. Zuwiderhandlungen verpflichten zu Schadenersatz. Alle Rechte fur den Fall der Patenterteilung oder GM-Eintragung vorbehalten freig.: HS. released Copying of this document, disclosing it to third parties or using the contents there for any purposes without express written authorization by use illegally forbidden. Any offenders are liable to pay all relevant damages.