NISSEI-ARCOTRONICS R77
Bulk Taped
Fig. 1 Fig. 2
p = 10 p ≥ 15
Ød ±
0.05 0.6 0.8
Fig. 1 Fig 2
P2 12.70 19.05
All dimensions are in mm.
MMKP Series
POLYPROPYLENE CAPACITOR WITH DOUBLE
SIDED METALLIZED FILM ELECTRODES
A.C. APPLICATIONS
Typical applications: electronic lighting (i.e. car headlamp
and ballast), pulse applications with high A.C. voltage and
high current.
SERIES CODE: R77
PART NUMBERING SYSTEM
1 2 3 4 5 6 7 8
[ ]
1. Series code
2. Capacitance value in pico farads. First 2
digits are significant and 3rd digit indicates
number of zeros.
3. Capacitance tolerance
H = 2.5% J = 5% K = 10%
4. A.C. voltage
5. Packaging code
B = bulk A = ammo R = reel
6. Lead spacing (mm)
F = 10 I = 15 N = 22.5
R = 27.5
7. Lead length (mm) – (Applies to bulk
packaging only. Omit for standard lead
length 4-6mm.)
L = 24-27 T = 3.5-4.0 V = 2.7-3.3
8. Internal code
GENERAL TECHNICAL DATA
Dielectric: polypropylene film
Plates: double-sided metallized polyester film
Winding: non-inductive type
Leads: tinned wire
Protection: plastic case, epoxy resin filled.
Box material is solvent resistant and flame
retardant according to UL94 V0
Marking: manufacturer’s logo, series (R77), dielectric
code (MKP), capacitance, tolerance, A.C.
voltage, manufacturing date code
Climatic category: 55/100/56 IEC 60068-1
Operating temperature range: -55 to +105°C
Related documents: IEC 60384-16; IEC 60384-17
CECC 31200
Typical application: LAMP CAPACITOR IN ELECTRONIC BALLAST
EMI filter
Rectifier
bridge
Step-up
circuit
Switching
circuit
EMI filter
Rectifier
bridge
Step-up
circuit
Switching
circuit
R77
R77
R77
R77
R77
R 7 7
~
Typical European scheme
~
Typical U.S. scheme
NISSEI-ARCOTRONICS R77
MMKP Series
POLYPROPYLENE CAPACITOR WITH DOUBLE
SIDED METALLIZED FILM ELECTRODES
A.C. APPLICATIONS
SERIES CODE: R77
Rated
Cap. 250Vac* (1 section) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
0.010µF 4.0 9.0 13.0 10.0 1500 190 E4 R77103-250-F-
0.012µF 4.0 9.0 13.0 10.0 1500 190 E4 R77123-250-F-
0.015µF 5.0 11.0 13.0 10.0 1500 190 E4 R77153-250-F-
0.018µF 6.0 12.0 13.0 10.0 1500 190 E4 R77183-250-F-
0.022µF 6.0 12.0 13.0 10.0 1500 190 E4 R77223-250-F-
0.027µF 6.0 12.0 18.0 15.0 900 110 E4 R77273-250-I-
0.033µF 6.0 12.0 18.0 15.0 900 110 E4 R77333-250-I-
0.039µF 6.0 12.0 18.0 15.0 900 110 E4 R77393-250-I-
0.047µF 7.5 13.5 18.0 15.0 900 110 E4 R77473-250-I-
0.056µF 7.5 13.5 18.0 15.0 900 110 E4 R77563-250-I-
0.068µF 8.5 14.5 18.0 15.0 900 110 E4 R77683-250-I-
0.082µF 10.0 16.0 18.0 15.0 900 110 E4 R77823-250-I-
0.10µF 10.0 16.0 18.0 15.0 900 110 E4 R77104-250-I-
Tolerance: H (±2.5%); J (± 5%); K (±10%)
Packaging code: B (bulk); A (ammo); R (reel)
Lead length (mm): L (24-27); T (3.5-4.0); V (2.7-3.3)
Omit for standard (4-6)
All dimensions are in mm.
* Not suitable for across-the-line applications. Please
refer to Interference Suppression Capacitors, page ???
Rated
Cap. 300Vac (2 sections) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
0.010µF 5.0 11.0 18.0 15.0 2500 400 E4 R77103-300-I-
0.012µF 5.0 11.0 18.0 15.0 2500 400 E4 R77123-300-I-
0.015µF 5.0 11.0 18.0 15.0 2500 400 E4 R77153-300-I-
0.018µF 5.0 11.0 18.0 15.0 2500 400 E4 R77183-300-I-
0.022µF 6.0 12.0 18.0 15.0 2500 400 E4 R77223-300-I-
0.027µF 6.0 12.0 18.0 15.0 2500 400 E4 R77273-300-I-
0.033µF 7.5 13.5 18.0 15.0 2500 400 E4 R77333-300-I-
0.039µF 7.5 13.5 18.0 15.0 2500 400 E4 R77393-300-I-
0.047µF 8.5 14.5 18.0 15.0 2500 400 E4 R77473-300-I-
0.056µF 10.0 16.0 18.0 15.0 2500 400 E4 R77563-300-I-
0.068µF 10.0 16.0 18.0 15.0 2500 400 E4 R77683-300-I-
0.056µF 6.0 15.0 26.5 22.5 1500 240 E4 R77563-300-N-
0.068µF 7.0 16.0 26.5 22.5 1500 240 E4 R77683-300-N-
0.082µF 8.5 17.0 26.5 22.5 1500 240 E4 R77823-300-N-
0.10µF 8.5 17.0 26.5 22.5 1500 240 E4 R77104-300-N-
Tolerance: H (±2.5%); J (± 5%); K (±10%)
Packaging code: B (bulk); A (ammo); R (reel)
Lead length (mm): L (24-27); T (3.5-4.0); V (2.7-3.3)
Omit for standard (4-6)
Rated
Cap. 400Vac (2 sections) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
5600ρF 5.0 11.0 18.0 15.0 3300 660 E4 R77562-400-I-
6800ρF 5.0 11.0 18.0 15.0 3300 660 E4 R77682-400-I-
8200ρF 5.0 11.0 18.0 15.0 3300 660 E4 R77822-400-I-
0.010µF 6.0 12.0 18.0 15.0 3300 660 E4 R77103-400-I-
0.012µF 6.0 12.0 18.0 15.0 3300 660 E4 R77123-400-I-
0.015µF 7.5 13.5 18.0 15.0 3300 660 E4 R77153-400-I-
0.018µF 7.5 13.5 18.0 15.0 3300 660 E4 R77183-400-I-
0.022µF 8.5 14.5 18.0 15.0 3300 660 E4 R77223-400-I-
0.027µF 10.0 16.0 18.0 15.0 3300 660 E4 R77273-400-I-
0.033µF 10.0 16.0 18.0 15.0 3300 660 E4 R77333-400-I-
0.027µF 6.0 15.0 26.5 22.5 2100 420 E4 R77273-400-N-
0.033µF 7.0 16.0 26.5 22.5 2100 420 E4 R77333-400-N-
0.039µF 7.0 16.0 26.5 22.5 2100 420 E4 R77393-400-N-
0.047µF 8.5 17.0 26.5 22.5 2100 420 E4 R77473-400-N-
0.056µF 8.5 17.0 26.5 22.5 2100 420 E4 R77563-400-N-
0.068µF 10.0 18.5 26.5 22.5 2100 420 E4 R77683-400-N-
0.082µF 10.0 18.5 26.5 22.5 2100 420 E4 R77823-400-N-
0.10µF 11.0 20.0 26.5 22.5 2100 420 E4 R77104-400-N-
Rated
Cap. 500Vac (2 sections) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
1000ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77102-500-I-
1200ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77122-500-I-
1500ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77152-500-I-
1800ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77182-500-I-
2200ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77222-500-I-
2700ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77272-500-I-
3300ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77332-500-I-
3900ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77392-500-I-
4700ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77472-500-I-
5600ρF 5.0 11.0 18.0 15.0 4500 1200 E4 R77562-500-I-
6800ρF 6.0 12.0 18.0 15.0 4500 1200 E4 R77682-500-I-
8200ρF 6.0 12.0 18.0 15.0 4500 1200 E4 R77822-500-I-
0.010µF 7.5 13.5 18.0 15.0 4500 1200 E4 R77103-500-I-
0.012µF 7.5 13.5 18.0 15.0 4500 1200 E4 R77123-500-I-
0.015µF 8.5 14.5 18.0 15.0 4500 1200 E4 R77153-500-I-
0.018µF 10.0 16.0 18.0 15.0 4500 1200 E4 R77183-500-I-
0.022µF 10.0 16.0 18.0 15.0 4500 1200 E4 R77223-500-I-
0.018µF 6.0 15.0 26.5 22.5 2500 650 E4 R77183-500-N-
0.022µF 7.0 16.0 26.5 22.5 2500 650 E4 R77223-500-N-
0.027µF 7.0 16.0 26.5 22.5 2500 650 E4 R77273-500-N-
0.033µF 8.5 17.0 26.5 22.5 2500 650 E4 R77333-500-N-
0.039µF 10.0 18.5 26.5 22.5 2500 650 E4 R77393-500-N-
0.047µF 10.0 18.5 26.5 22.5 2500 650 E4 R77473-500-N-
0.056µF 11.0 20.0 26.5 22.5 2500 650 E4 R77563-500-N-
0.068µF 11.0 20.0 32.0 27.5 1100 290 E4 R77683-500-R-
0.082µF 11.0 20.0 32.0 27.5 1100 290 E4 R77823-500-R-
0.10µF 13.0 22.0 32.0 27.5 1100 290 E4 R77104-500-R-
Tolerance: H (±2.5%); J (± 5%); K (±10%)
Packaging code: B (bulk); A (ammo); R (reel)
Lead length (mm): L (24-27); T (3.5-4.0); V (2.7-3.3)
Omit for standard (4-6)
Note: If the working voltage (V) is lower than the rated voltage (VR), the capacitor may work at higher dv/dt. In this case
the maximum value allowed is obtained multiplying the above value (see table dv/dt) with the ratio VR /V. The
pulse characteristic K0 depends on the voltage waveform and in any case it cannot exceed the value given in the
above table. The dv/dt test is carried out at 2 times the above values.
polypropylene film
double-sided metallized
polyester carrier film
single side metallized
polypropylene film
1 section
(250Vac)
2 sections
(300-400-500Vac)
NISSEI-ARCOTRONICS R77
MMKP Series
POLYPROPYLENE CAPACITOR WITH DOUBLE
SIDED METALLIZED FILM ELECTRODES
A.C. APPLICATIONS
SERIES CODE: R77
Rated
Cap. 700Vac (3 sections) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
1000ρF 5.0 11.0 18.0 15.0 9500 3000 E4 R77102-700-I-
1200ρF 5.0 11.0 18.0 15.0 9500 3000 E4 R77122-700-I-
1500ρF 5.0 11.0 18.0 15.0 9500 3000 E4 R77152-700-I-
1800ρF 5.0 11.0 18.0 15.0 9500 3000 E4 R77182-700-I-
2200ρF 5.0 11.0 18.0 15.0 9500 3000 E4 R77222-700-I-
2700ρF 6.0 12.0 18.0 15.0 9500 3000 E4 R77272-700-I-
3300ρF 6.0 12.0 18.0 15.0 9500 3000 E4 R77332-700-I-
3900ρF 7.5 13.5 18.0 15.0 9500 3000 E4 R77392-700-I-
4700ρF 7.5 13.5 18.0 15.0 9500 3000 E4 R77472-700-I-
5600ρF 8.5 14.5 18.0 15.0 9500 3000 E4 R77562-700-I-
6800ρF 8.5 14.5 18.0 15.0 9500 3000 E4 R77682-700-I-
8200ρF 10.0 16.0 18.0 15.0 9500 3000 E4 R77822-700-I-
8200ρF 6.0 15.0 26.5 22.5 4500 1400 E4 R77822-700-N-
0.010µF 6.0 15.0 26.5 22.5 4500 1400 E4 R77103-700-N-
0.012µF 7.0 16.0 26.5 22.5 4500 1400 E4 R77123-700-N-
0.015µF 8.5 17.0 26.5 22.5 4500 1400 E4 R77153-700-N-
0.018µF 10.0 18.5 26.5 22.5 4500 1400 E4 R77183-700-N-
0.022µF 10.0 18.5 26.5 22.5 4500 1400 E4 R77223-700-N-
0.027µF 11.0 20.0 26.5 22.5 4500 1400 E4 R77273-700-N-
Tolerance: J (± 5%); K (±10%)
Packaging code: B (bulk); A (ammo); R (reel)
Lead length (mm): L (24-27); S (4-6); T (3.5-4.0); V (2.7-3.3)
Omit for standard (4-6)
All dimensions are in mm.
Rated
Cap. 900Vac (4 sections) Max
dv/dt Max K0 Part Number
B H L P (V/µs) (V2/µs)
1000ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77102-900-N-
1200ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77122-900-N-
1500ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77152-900-N-
1800ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77182-900-N-
2200ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77222-900-N-
2700ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77272-900-N-
3300ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77332-900-N-
3900ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77392-900-N-
4700ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77472-900-N-
5600ρF 6.0 15.0 26.5 22.5 9500 3800 E4 R77562-900-N-
6800ρF 7.0 16.0 26.5 22.5 9500 3800 E4 R77682-900-N-
8200ρF 7.0 16.0 26.5 22.5 9500 3800 E4 R77822-900-N-
0.010µF 8.5 17.0 26.5 22.5 9500 3800 E4 R77103-900-N-
0.012µF 10.0 18.5 26.5 22.5 9500 3800 E4 R77123-900-N-
0.015µF 10.0 18.5 26.5 22.5 9500 3800 E4 R77153-900-N-
0.018µF 11.0 20.0 26.5 22.5 9500 3800 E4 R77183-900-N-
Tolerance: J (± 5%); K (±10%)
Packaging code: B (bulk); A (ammo); R (reel)
Lead length (mm): L (24-27); S (4-6); T (3.5-4.0); V (2.7-3.3)
Omit for standard (4-6)
Note: If the working voltage (V) is lower than the rated voltage (VR), the capacitor may work at higher dv/dt. In this case
the maximum value allowed is obtained multiplying the above value (see table dv/dt) with the ratio VR /V. The
pulse characteristic K0 depends on the voltage waveform and in any case it cannot exceed the value given in the
above table. The dv/dt test is carried out at 2 times the above values.
polypropylene film
polypropylene film
double-sided metallized
polyester carrier film
double-sided metallized
polyester carrier film 4 sections
(900Vac)
single side metallized
polypropylene film
3 sections
(700Vac)
NISSEI-ARCOTRONICS R77
MMKP Series
POLYPROPYLENE CAPACITOR WITH DOUBLE
SIDED METALLIZED FILM ELECTRODES
A.C. APPLICATIONS
SERIES CODE: R77
ELECTRICAL CHARACTERISTICS
Rated voltage (VR): 250Vac ( 630Vdc) -300Vac (800Vdc)
400Vac (1000Vdc) -500Vac (1300Vdc)
700Vac (1600Vdc) -900Vac (2000Vdc)
Rated temperature (TR): + 85°C for VR (d.c)
+105°C for VR (a.c)
Voltage derating vs. temperature:
for temperatures between +85°C and +105°C a decreasing factor
of 1.25% per °C on the rated voltage VR has to be applied.
Capacitance range:
1000ρF to 0.1µF
Capacitance values:
E 12 series (IEC 60063 Norm)
Capacitance tolerances (measured at 1 kHz):
±2.5% (H); ±5% (J); 10% (K)
Total self-inductance (L): (lead length ~2mm)
Pitch (mm) 10 15 22.5 27.5
L (nH) ≈ 9 10 18 18
Dissipation factor (DF):
tgδ×10-4 at +25°C ± 5°C
KHz tgδ×10-4
10
100 ≤ 6
≤ 10
Insulation resistance:
Test conditions
Temperature: +25°C ± 5°C
Voltage charge time: 1 min
Voltage charge: 100Vdc
Performance
≥ 1 x 105 MΩ (Typ. value: 5 x 105 MΩ)*
Test voltage between terminations:
1.6×VR applied for 2 s at +25°C ± 5°C
TEST METHOD AND PERFORMANCE
Test conditions
Temperature: +40°C ± 2°C
Relative humidity (RH): 93% ± 2%
Test duration: 56 days
Performance
Capacitance change (∆C/C): ≤ 2%
DF change (∆tgδ): ≤ 10×10-4 at 1kHz
Insulation resistance: ≥ 50% of initial limit
Endurance:
Test conditions
Temperature: +105°C ± 2°C
Test duration: 2000 h
Voltage applied: 1.25×VR (a.c.) at 50Hz
Performance
Capacitance change (∆C/C): ≤ 2%
DF change (∆tgδ): ≤ 10×10-4 at 10kHz
Insulation resistance: ≥ 50% of initial limit
Resistance to soldering heat:
Test conditions
Solder bath temperature: +260°C ± 5°C
Dipping time (with heat screen): 10 s ± 1 s
Performance
Capacitance change (∆C/C): ≤ 1%
DF change (∆tgδ): ≤ 10×10-4 at 10kHz
Insulation resistance: ≥ initial limit
Long term stability (after two years):
Storage: standard environmental conditions (see general
information)
Performance
Capacitance change (∆C/C): ≤ 0.5%
NISSEI-ARCOTRONICS R77
MMKP Series
POLYPROPYLENE CAPACITOR WITH DOUBLE
SIDED METALLIZED FILM ELECTRODES
A.C. APPLICATIONS
SERIES CODE: R77
MAX. VOLTAGE (Vrms) VERSUS FREQUENCY (sinusoidal waveform / Th ≤ 40°C)
Note: p (pitch) in mm
